$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x Replacement V6 Coolant Cap
2 x 9000 Shifter Bushing Repair Kit
1 x B207 Coolant Cap
1 x Limit Strap Coilover Add On Kit
1 x Con Rods V6 2.8L 155.8mm
1 x Troll Head Plug
1 x T7 Head Plug NGK
3 x SCNA Christmas Calendar
1 x Injectors Green Giant 42lb (set 4)
1 x Map/MAT sensor weld bung
1 x Fuel Pressure Regulator 4.0 bar
1 x Universal / Special Request
4 x ATF Saab 3309 (Automatic 02->)
1 x K&N Filter Service Kit
3 x Rivetnuts Pair (2pcs)
3 x PPC - Upgrade from stage 1 to stage 3
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
2 x MTF0063 Manual Gear oil
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
2 x AEM Wideband Gauge Kit
1 x Shifter Alignment Pins (Set 2)
1 x Header Flange Stainless Blended Transition B2x4,B2x5
2 x Moog Ball Joint
1 x Head Bolt Washers
1 x Injectors Siemens 60lb 630cc (set 4)
2 x IAT Weld Bung T5/Bosch
2 x Injectors Siemens 80lb 875cc (set 4)
1 x Intake Flange B2x4 T5
1 x Viggen Titanium KeyChain
2 x Saab black Keychain
2 x Clear Little Fender Blinkers Factory Saab
2 x Shift Rod Bushings
1 x Hood Emblem 9-3 SS/sc 03- All
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Sparkplugs 9-3SS
2 x 3 Point Hardware
1 x Headlight Connector Repair Kit 9-3SS 9-5
2 x Brake Vac pump seals
2 x Steering Coupler 9-3 99-02
1 x 9-3/NG900 Shift Knobs Leather
1 x Crush Sleeve F35 F25
1 x Ignition Coil 9-3SS 2.8t and 2.8T
2 x Replacement Hardware Pack 6-Point
2 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
2 x InjectorDynamics 725cc For 2.8V6 (Set6)
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
2 x Midpipe 2.8T FWD (2wd)
1 x BSR Optiflow Intake 4cyl w SAI
1 x BSR Optiflow Replacement Filter V6 2.8
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
2 x BSR Optiflow Intake V6 2.8t
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Weld Bungs -Taper- Race Only
2 x V6 Tank Float - SparePart
1 x Oil Cap GM "HHR"
1 x Downpipe Hardware Kit
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Filter 9-5 Cabin Air
1 x BSR 9-5 2010-2011 V6 300Hp
2 x 9-3 ng900 Hood Protection Strip
1 x Oil Cooler Adaptor B2X5
2 x Exhaust manifold Stud Kit
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Transmission Nut F35 F25
2 x Exhaust Clamp Kit
1 x Shifter Top Ghost Logo
3 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
2 x Alu Hybrid Flywheel For NG900/9-3
1 x Quaife Differential 9-5 and Viggen (F35)
1 x ARP Ring Gear Bolts F25/F35
1 x T7 3.5 Bar Fuel Pressure Regulator
2 x Fog light Replacement Panels
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x Flywheel Twin Disk 7.25in B2xx
3 x Rear Engine Mount 4cyl
1 x Antenna Plug NG900/9-3 hatchback
1 x T7 Injector Spacer Kit
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x 9-3 /NG900 Grille
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Replacement Flywheel Insert NG900/9-3
1 x Aluminum Flywheel For NG900/9-3
1 x Throttle Bend for T5 94-99
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Fog light 9-3 left 99-00
3 x Slave Cyl
2 x ARP Exhaust Manifold Stud kit Stainless
2 x Remote Button NG900
1 x 9-5 Aero Sill Protection
1 x Headbolts (New Style)
1 x Basic Subframe Brace
1 x 9-5 Exhaust Flex Pipe Stainless
1 x 20th Viggen logo Shifter Top
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
1 x Front Camber Adjustment Bolts
1 x Air Filter 06 version (All 9-5)
1 x Rod Bearings only Pauter Rods
1 x 9-5 Wheel 10-Spoke 16in.
1 x Replacement Filter for Open air 9-3 T7
1 x 9-3 ng900 radio wires
1 x 9-5 Rear Brake rotor See Description
1 x Oil Filter Re-locator
1 x 9-3 Rear Ashtray
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Crank Vent Kit #6 T7 4cyl
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
2 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x Goodridge Brake Lines 9-3 SS / SC 03-
1 x 9000 High Performance Brake Line Kit '95-'98
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x 9-5 High Performance Brake Line Kit
1 x c900 Performance Brake lines
1 x Custom Brake Lines RR 300mm Kit
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x 9-5 Open Air Prefilter
1 x 9-3 SS Akebono Rear Pads
1 x Downpipe 2.8T FWD (2wd)
2 x Optical Cable Connector (Onstar Delete)
1 x v6 2.8t SAI Delete Kit
1 x Downpipe 2.8T XWD (4wd)
1 x Fog light 9-3 Right 99-00
1 x Viggen Fog Air Intake
1 x Hawk HPS FRONT Pads 9-3 TurboX (345mm)
1 x Rear Pedestal Spoiler 9-3 SS
1 x Rear Rotors PAIR 292mm Plain (Code: BB)
1 x Rear Rotors PAIR 292mm XWD (Code: BC)
1 x Throttle Body T7
1 x Valve Cover Gasket Set 4cyl
1 x Turbo Bypass Valve
1 x Storage Tray / Ashtray Kit 9-5 10-
1 x Rear Rotors PAIR 278mm Plain (Code: BA)
1 x Floormats BSR 9-3 99-02 900 94-98
1 x Rear Brake Pads 9-5 Later Style
1 x 9-5 Blend Flap Limit Lever 99-04
1 x Forge Bypass Valve Cobalt/HHR TC
1 x PPC 3 Volvo Diagnostic System
1 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x Viggen Clutch Kit 99-02
1 x Fog light Replacement Panels 99-01
1 x Bulb Switch Light
$29,812.96
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail