$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x MTF0063 Manual Gear oil
2 x Shifter Alignment Pins (Set 2)
2 x ATF Saab 3309 (Automatic 02->)
2 x Oil Cap GM "HHR"
2 x Short Shifter HHR Cobalt F35 F40
2 x SCNA Christmas Calendar
2 x Replacement V6 Coolant Cap
1 x B207 Coolant Cap
1 x Limit Strap Coilover Add On Kit
2 x PPC 3 Volvo Diagnostic System
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Viggen Titanium KeyChain
1 x Universal / Special Request
1 x Rivetnuts Pair (2pcs)
2 x Injectors Green Giant 42lb (set 4)
1 x Header Flange Stainless Blended Transition B2x4,B2x5
4 x Moog Ball Joint
2 x T5 3.0 Bar Map Sensor Adaptor
2 x Intake Flange B2x4 T5
2 x Head Bolt Washers
1 x PPC - Upgrade from stage 1 to stage 3
2 x Injectors Siemens 80lb 875cc (set 4)
2 x c900 Performance Brake lines
1 x Oil Cap 9-3SS V6 "Ghost"
2 x 9-3 ng900 radio wires
1 x Oil Filter Re-locator
1 x Direct Ignition T5 RED
1 x Aluminum Flywheel For NG900/9-3
2 x 9-3SS Wheel 5-Spoke Low Split 17 in.
2 x Exhaust Clamp Kit
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Clear Little Fender Blinkers Factory Saab
2 x Shift Rod Bushings
1 x v6oilcoolplate
1 x 3 Point Hardware
1 x Oil Cap 9-3SS "Ghost"
1 x Crush Sleeve F35 F25
1 x Transmission Nut F35 F25
2 x Exhaust manifold Stud Kit
1 x 9000 Shifter Bushing Repair Kit
1 x Front Camber Adjustment Bolts
1 x Machined Control Arm Kit
1 x Saab black Keychain
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
2 x Downpipe Hardware Kit
1 x BSR Optiflow Intake 4cyl
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x 9-5 Open Air Prefilter
1 x Filter 9-5 Cabin Air
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Fuel Pressure Regulator 4.0 bar
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x 9-3 SS Akebono Rear Pads
1 x BSR Optiflow Replacement Filter V6 2.8
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Cat Back Exh for 9000 CS, CSE AERO
$9,787.12
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail