$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Head Bolt Washers
4 x Clear Little Fender Blinkers Factory Saab
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Saab black Keychain
1 x Replacement V6 Coolant Cap
1 x 9-3/NG900 Shift Knobs Leather
2 x 9-5 Aero Sill Protection
1 x Exhaust manifold Stud Kit
2 x Rivetnuts Pair (2pcs)
2 x Map/MAT sensor weld bung
1 x T7 3.5 Bar Fuel Pressure Regulator
3 x Exhaust Clamp Kit
1 x Turbo Conversion Pipe 900 9-3 T5
3 x ARP Exhaust Manifold Stud kit Stainless
3 x Flex Pipe 900 94-98 9-3 99-02
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
2 x Viggen Fog Air Intake
2 x Weld Bungs -Taper- Race Only
2 x Cat back for Viggen 2.5in
3 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Throttle Bend for T5 94-99
1 x Basic Subframe Brace
3 x Genuine Saab 4cyl Oil Filters
1 x T7 Head Plug NGK
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x Replacement Hardware Pack 6-Point
2 x Replacement Flywheel Insert NG900/9-3
1 x Balance Shaft Tensioner Delete
1 x Shifter Top Ghost Logo
1 x Fog light 9-3 Right 99-00
1 x Rear Camber Shims Kit 6pcs
1 x Sport Transmission Mount 9-3/900 (Automatic)
2 x Direct Ignition T7 Black
1 x Crush Sleeve F35 F25
1 x Direct Ignition T5 RED
1 x Replacement Filter for Open air 9-3 T7
1 x Fuel Line Clip
1 x 9-3 /NG900 Grille
2 x Headbolts (New Style)
4 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Mass Airflow Meter T7
1 x Flywheel Twin Disk 7.25in B2xx
1 x Downpipe Hardware Kit
1 x JE Piston Rings 90.0mm 235/205
1 x Oil Filter Re-locator
1 x Remote Button NG900
1 x Shift Rod Bushings
1 x Slave Cyl
1 x 4340 Connecting Rods B204 B235
2 x Rear Engine Mount 4cyl
4 x Limit Strap Coilover Add On Kit
1 x Rear spring perches Adjustable NG900/9-3
2 x ARP Ring Gear Bolts F25/F35
2 x Aluminum Flywheel For NG900/9-3
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Crank Vent Kit #6 T7 4cyl
1 x Fog light Replacement Panels
2 x Machined Control Arm Kit
4 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x Antenna Plug NG900/9-3 hatchback
3 x Steering Coupler 9-3 99-02
1 x Rod Bearings only Pauter Rods
1 x 9-3 ng900 Hood Protection Strip
2 x Transmission Nut F35 F25
1 x Head Stud Kit all 4cyl
1 x Steering Rod Bushings NG900/93
1 x Alu Hybrid Flywheel For NG900/9-3
1 x PPC 3 Volvo Diagnostic System
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Fog light 9-3 left 99-00
1 x Fuel Pressure Regulator 4.0 bar
2 x Universal / Special Request
1 x IAT Weld Bung T5/Bosch
1 x Injectors Siemens 60lb 630cc (set 4)
3 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Intake Flange B2x4 T5
2 x Moog Ball Joint
1 x Injectors Green Giant 42lb (set 4)
3 x c900 Performance Brake lines
3 x PPC - Upgrade from stage 1 to stage 3
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x Sparkplugs 9-3SS
2 x B207 Coolant Cap
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x V6 Tank Float - SparePart
1 x ShortShift Kit 93ss
2 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x BSR Optiflow Replacement Filter V6 2.8
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x Rear Pedestal Spoiler 9-3 SS
2 x 3 Point Hardware
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
2 x Midpipe 2.0T 07-11 FWD (2wd)
1 x 20th Viggen logo Shifter Top
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Throttle Body T7
1 x Goodridge Brake Lines 9-3 SS / SC 03-
1 x BSR Optiflow Intake 4cyl
1 x T7 Injector Spacer Kit
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Oil Cooler Adaptor B2X5
1 x Upgrade Valve Springs T5 Cars
1 x Troll Head Plug
1 x v6 header flange
1 x Brembo Kit 315mm Hawk HPS Pads
1 x K&N Filter Service Kit
1 x Coreganizer
1 x BSR 9-5 2010-2011 V6 300Hp
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Oil Cap 9-3SS "Ghost"
1 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x Hawk HPS FRONT Pads 9-3 TurboX (345mm)
1 x Ceramic Low Dust Brake Pads 9-3 SS
1 x Shifter Mount Kit Cobalt/ HHR
1 x 9000 Intercooler ETS
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x BBS Center Cap for 9-2x RK small caps
$29,224.99
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail