$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

After doing the front install, I thought others would benefit from my mistakes. I installed the kit on a MY95 900.

Tools Needed:
Flat Blade screwdriver
11,14,17mm Socket
Jack and Jack Stands
Drain Pan
10mm Flare (Brake Line) Wrench
Channel Locks
7mm Allen (Hex) wrench
19,24mm Open-End Wrench
Torque Wrench

Jack up front of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (Flat blade and 17mm).

Place drain pan under caliper.

Remove banjo (from brake line to caliper) bolt, try to find the brass washers on both sides of the bolt (11mm socket).

Disconnect the solid brake line from flexible house, the 10mm little nut on top of the mounting tab not the 17mm on the bottom of the mounting tab. The 17mm can be used to hold the line in place if need be, I did not need to. (10mm flare wrench).

Remove clip securing the flexible line to the mounting point, slide the line out of the mounting point (channel locks).

Install new brake line to caliper, the fitting should be angled away from the caliper. Make sure to put a new brass washer on each side of the banjo bolt. Also, make sure the brake line does not interfere with accessing the caliper guide pin. (14mm socket, torque wrench, 7mm allen wrench).

Install new line into mounting point, hold bottom with 19mm wrench and tighten bolt with 24mm wrench (19,24mm wrench).

Install solid brake line into fitting on end of SS line (10mm flare wrench).

Bleed Brakes.

Re-install wheel/tire and lower vehicle.

I will write instructions for the rear lines as a separate review.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x SCNA Christmas Calendar
1 x Viggen Titanium KeyChain
1 x Troll Head Plug
1 x Con Rods V6 2.8L 155.8mm
1 x c900 Performance Brake lines
2 x Limit Strap Coilover Add On Kit
1 x 9000 Shifter Bushing Repair Kit
2 x Replacement V6 Coolant Cap
2 x B207 Coolant Cap
2 x Clear Little Fender Blinkers Factory Saab
2 x K&N Filter Service Kit
2 x Shifter Alignment Pins (Set 2)
3 x MTF0063 Manual Gear oil
3 x PPC - Upgrade from stage 1 to stage 3
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Injectors Siemens 60lb 630cc (set 4)
2 x IAT Weld Bung T5/Bosch
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
5 x 9-5 Aero Sill Protection
2 x Oil Cap GM "HHR"
3 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Shifter Mount Kit Cobalt/ HHR
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
3 x Forge Bypass Valve Cobalt/HHR TC
2 x Short Shifter HHR Cobalt F35 F40
1 x Adaptor Harness Handsfree 01-
1 x Fog light Replacement Panels 99-01
2 x 20th Viggen logo Shifter Top
3 x T7 3.5 Bar Fuel Pressure Regulator
2 x T7 Injector Spacer Kit
2 x Aero Clutch Kit 9-5
1 x Replacement Filter for Open air 9-3 T7
2 x Crush Sleeve F35 F25
1 x Basic Subframe Brace
2 x 9-3 /NG900 Grille
2 x Replacement Hardware Pack 6-Point
2 x Drop in Sport Filter 9-5
3 x Rear Engine Mount 4cyl
1 x Rear Camber Shims Kit 6pcs
1 x Fog light 9-3 Right 99-00
1 x Fog light Replacement Panels
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
2 x Direct Ignition T5 RED
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Steering Rod Bushings NG900/93
3 x Open Air Intake 9-3 00-02 and Viggen (All T7)
2 x Coreganizer
1 x JE Piston Rings 90.0mm 235/205
1 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x ARP Exhaust Manifold Stud kit Stainless
1 x Floormats BSR 9-5
1 x Shifter Top Ghost Logo
1 x Cabin Vent Fan
2 x 9-5 Exhaust Flex Pipe Stainless
1 x Exhaust Clamp Kit
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Crank Vent Kit #6 T7 4cyl
1 x Head Stud Kit all 4cyl
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Shift Rod Bushings
1 x Transmission Nut F35 F25
1 x Antenna Plug NG900/9-3 hatchback
2 x 9-5 Wheel 5-Spoke Twin 17in
2 x Oil Cap 9-3SS V6 "Ghost"
1 x Oil Cap 9-3SS V6 "Griffin"
1 x 9-3/NG900 Shift Knobs Leather
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
3 x Mat Set Black Rubber 9-5 10-
1 x 9-3 ng900 Hood Protection Strip
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Head Bolt Washers
1 x Saab black Keychain
2 x Mat Set Textile Jet Black 9-5 10-
3 x BSR 9-5 2010-2011 V6 300Hp
2 x Mat Set Textile Parchment 9-5 10-
2 x Storage Tray / Ashtray Kit 9-5 10-
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x 9-5 Wheel 10-Spoke 16in.
1 x ATF Saab 3309 (Automatic 02->)
1 x 9-5 Textile Mats 98-07
1 x 9-5 Shift Knobs Leather
2 x Mat Set Textile Shark Grey 9-5 10-
2 x Air Filter 06 version (All 9-5)
1 x 9-5 Rear Brake rotor See Description
1 x Front Camber Adjustment Bolts
2 x Front Camber Adjustment Bolts
2 x Rivetnuts Pair (2pcs)
1 x Floormats BSR 9-3 99-02 900 94-98
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
1 x Upgrade Valve Springs T5 Cars
1 x B207 Upper Radiator Coolant T
1 x 9-5 Blend Flap Limit Lever 99-04
2 x Viggen Clutch Kit 99-02
1 x Rear Brake Pads 9-5 Later Style
1 x Injectors 175hp Stg3 (Set4)
1 x Headlight Bulb H7 Longer Life
1 x Rear Rotors PAIR 278mm Plain (Code: BA)
1 x Cigarette Lighter
1 x Bulb Switch Light
2 x Remote Button NG900
1 x Downpipe Hardware Kit
1 x 9-5 Intercooler ETS
1 x BSR 9-5 260Hp 2006-
1 x Downpipe 2.8T FWD (2wd)
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Filter 9-5 Cabin Air
1 x 9-5 Open Air Prefilter
1 x Genuine Saab 4cyl Oil Filters
1 x Rear Pedestal Spoiler 9-3 SS
1 x Sparkplugs 9-3SS
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
2 x Throttle Body T7
1 x Mass Airflow Meter T7
1 x Hood Emblem 9-3 SS/sc 03- All
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Headbolts (New Style)
2 x BSR Optiflow Intake 4cyl
1 x Fuel Line Clip
1 x Front Rotors PAIR 285mm Plain (Code: AA)
$29,118.74
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail