$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x AEM Wideband Gauge Kit
1 x Moog Ball Joint
1 x PPC - Upgrade from stage 1 to stage 3
1 x Universal / Special Request
1 x T5 3.0 Bar Map Sensor Adaptor
1 x IAT Weld Bung T5/Bosch
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Map/MAT sensor weld bung
1 x Rivetnuts Pair (2pcs)
2 x Fuel Pressure Regulator 4.0 bar
1 x Intake Flange B2x4 T5
1 x Injectors Green Giant 42lb (set 4)
2 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Injectors Siemens 60lb 630cc (set 4)
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Head Bolt Washers
1 x Oil Cap GM "HHR"
1 x Shifter Alignment Pins (Set 2)
1 x Midpipe 2.0T 07-11 FWD (2wd)
2 x 9-5 Aero Sill Protection
1 x Mat Set Textile Parchment 9-5 10-
2 x BSR 9-5 2010-2011 V6 300Hp
2 x Slave Cyl
2 x Aluminum Flywheel For NG900/9-3
2 x Oil Cap 9-3SS V6 "Griffin"
3 x Clear Little Fender Blinkers Factory Saab
1 x Crush Sleeve F35 F25
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x BSR Optiflow Replacement Filter V6 2.8
2 x BSR Optiflow Intake V6 2.8t
1 x Downpipe 2.8T FWD (2wd)
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Midpipe 2.8T FWD (2wd)
1 x 4 Cyl 2.0 Coolant Tank
1 x Injectors 175hp Stg3 (Set4)
1 x Downpipe 2.8T XWD (4wd)
1 x BSR Optiflow Intake 4cyl w SAI
1 x Open Air Intake 9000 93-98
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x MTF0063 Manual Gear oil
3 x Basic Subframe Brace
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
2 x B207 Coolant Cap
1 x BBS Center Cap for 9-2x RK small caps
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x 9-5 Wheel 10-Spoke 16in.
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
2 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Flywheel Twin Disk 7.25in B2xx
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Replacement Flywheel Insert NG900/9-3
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
1 x Mat Set Black Rubber 9-5 10-
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
2 x Custom Brake Lines RR 300mm Kit
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Crank Vent Kit #6 T7 4cyl
1 x Replacement Hardware Pack 6-Point
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Genuine Saab 4cyl Oil Filters
1 x 9-3 SS Akebono Rear Pads
1 x 9-3 /NG900 Grille
1 x Troll Head Plug
1 x T7 Head Plug NGK
1 x Front Camber Adjustment Bolts
1 x ARP Ring Gear Bolts F25/F35
1 x Transmission Nut F35 F25
1 x Shifter Top Ghost Logo
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Rear Engine Mount 4cyl
1 x Viggen Clutch Kit 99-02
1 x Cat back for Viggen 2.5in
1 x Exhaust Clamp Kit
1 x Turbo Bypass Valve
1 x Fuel Line Clip
$18,292.29
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail