$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Oil Cap GM "HHR"
2 x Short Shifter HHR Cobalt F35 F40
2 x Shifter Alignment Pins (Set 2)
1 x PPC 3 Volvo Diagnostic System
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
2 x Replacement V6 Coolant Cap
1 x c900 Performance Brake lines
2 x PPC - Upgrade from stage 1 to stage 3
1 x 9-5 Shift Knobs Leather
1 x Moog Ball Joint
1 x IAT Weld Bung T5/Bosch
2 x Intake Flange B2x4 T5
2 x 9-3 ng900 Hood Protection Strip
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
2 x 4340 Connecting Rods B204 B235
1 x Mass Airflow Meter T7
1 x Exhaust manifold Stud Kit
3 x Crush Sleeve F35 F25
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
4 x 20th Viggen logo Shifter Top
3 x Downpipe Hardware Kit
2 x Genuine Saab 4cyl Oil Filters
2 x 9-5 Blend Flap Limit Lever 99-04
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
3 x Flex Pipe 900 94-98 9-3 99-02
2 x Crank Vent Kit #6 T7 4cyl
2 x Direct Ignition T7 Black
1 x 9000 High Performance Brake Line Kit '95-'98
1 x Rear Engine Mount 4cyl
1 x Remote Button NG900
2 x 9-3 99-02,03 CV Antenna Adaptor
2 x Open Air Intake 9000 93-98
1 x T7 Head Plug NGK
1 x Clear Little Fender Blinkers Factory Saab
1 x Floormats BSR 9-3 99-02 900 94-98
1 x Cat Back Exh for 9000 CS, CSE AERO
2 x Rod Bearings only Pauter Rods
2 x Injectors Green Giant 42lb (set 4)
2 x JE Piston Rings 90.0mm 235/205
1 x 9-3 Rear Ashtray
2 x Exhaust Clamp Kit
1 x 9000 Shifter Bushing Repair Kit
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Balance Shaft Tensioner Delete
1 x 9-3 ng900 radio wires
2 x Oil Filter Re-locator
2 x 9-3 / 900 Uprated Front ARB Bushings
2 x Replacement Hardware Pack 6-Point
1 x Headbolts (New Style)
1 x 9-3/NG900 Shift Knobs Leather
1 x Coreganizer
1 x Direct Ignition T5 RED
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Mat Set Textile Jet Black 9-5 10-
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Fog light 9-3 Right 99-00
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Fog light Replacement Panels
1 x 9-3 /NG900 Grille
2 x Storage Tray / Ashtray Kit 9-5 10-
1 x Basic Subframe Brace
1 x Adaptor Harness Handsfree 01-
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x V6 Tank Float - SparePart
1 x Shift Rod Bushings
1 x v6oilcoolplate
1 x Griffin logo Shifter Top
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x Downpipe 2.8T FWD (2wd)
1 x Fuel Line Clip
1 x Mat Set Textile Shark Grey 9-5 10-
1 x Viggen Fog Air Intake
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x K&N Filter Service Kit
1 x Brembo Brake Kit 315mm 9-3 SS
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x T7 Injector Spacer Kit
1 x Alu Hybrid Flywheel For NG900/9-3
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Rivetnuts Pair (2pcs)
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Turbo Bypass Valve
1 x Filter 9-5 Cabin Air
1 x 9-3 SS Akebono Rear Pads
1 x Fuel Pressure Regulator 4.0 bar
1 x Cat back for Viggen 2.5in
1 x Mat Set Black Rubber 9-5 10-
1 x Steering Rod Bushings NG900/93
1 x Throttle Body T7
$19,653.73
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail