$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x Shifter Mount Kit Cobalt/ HHR
2 x Forge Bypass Valve Cobalt/HHR TC
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Head Bolt Washers
2 x 9-5 Wheel 5-Spoke Twin 17in
2 x T5 3.0 Bar Map Sensor Adaptor
1 x IAT Weld Bung T5/Bosch
2 x 9-5 Aero Sill Protection
1 x 9-5 Rear Brake rotor See Description
1 x 9-3 ng900 Hood Protection Strip
2 x Injectors Green Giant 42lb (set 4)
1 x 9-5 Wheel 10-Spoke 16in.
2 x Moog Ball Joint
2 x 9-3/NG900 Shift Knobs Leather
1 x Aero Clutch Kit 9-5
1 x 9-5 Shift Knobs Leather
1 x 9-3 /NG900 Grille
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Injectors Siemens 60lb 630cc (set 4)
4 x MTF0063 Manual Gear oil
1 x K&N Filter Service Kit
1 x AEM Wideband Gauge Kit
2 x Map/MAT sensor weld bung
2 x 9-3SS Wheel 5-Spoke Low Split 17 in.
2 x Rivetnuts Pair (2pcs)
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
3 x Universal / Special Request
1 x "Griffin" Valve stem caps
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Saab black Keychain
1 x Mat Set Black Rubber 9-5 10-
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Oil Cap 9-3SS V6 "Ghost"
2 x Shift Rod Bushings
2 x ARP Exhaust Manifold Stud kit Stainless
1 x 9000 Shifter Bushing Repair Kit
2 x 9000 High Performance Brake Line Kit '95-'98
2 x Crush Sleeve F35 F25
1 x 9000 Intercooler ETS
1 x Clear Little Fender Blinkers Factory Saab
3 x Exhaust manifold Stud Kit
1 x Cat Back Exh for 9000 CS, CSE AERO
2 x Open Air Intake 9000 93-98
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
1 x Midpipe 2.8T FWD (2wd)
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x ShortShift Kit 93ss
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x Midpipe 2.8T XWD (4wd)
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x Downpipe 2.8T FWD (2wd)
1 x BSR Optiflow Intake 4cyl w SAI
1 x Con Rods V6 2.8L 155.8mm
1 x Injectors 175hp Stg3 (Set4)
1 x Shifter Mount Kit 93ss
1 x Griffin logo Shifter Top
1 x 20th Viggen logo Shifter Top
2 x Coreganizer
1 x Downpipe 2.8T XWD (4wd)
1 x BSR Optiflow Replacement Filter V6 2.8
2 x Adaptor Harness Handsfree 01-
1 x 9-3 ng900 radio wires
2 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x B207 Coolant Cap
2 x Downpipe Hardware Kit
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Transmission Nut F35 F25
1 x Headbolts (New Style)
2 x 3 Point Hardware
1 x Ignition Coil 9-3SS 2.8t and 2.8T
2 x Exhaust Clamp Kit
1 x Fuel Line Clip
1 x Steering Coupler 9-3 99-02
2 x Cat back for Viggen 2.5in
1 x Steering Rod Bushings NG900/93
1 x Direct Ignition T7 Black
1 x Quaife Differential 9-5 and Viggen (F35)
1 x B207 Upper Radiator Coolant T
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Mass Airflow Meter T7
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x T7 Injector Spacer Kit
1 x Hood Emblem 9-3 SS/sc 03- All
1 x JE Piston Rings 90.0mm 235/205
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Slave Cyl
1 x Remote Button NG900
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Turbo Conversion Pipe 900 9-3 T5
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Sport Transmission Mount 9-3/900 (Automatic)
2 x ARP Ring Gear Bolts F25/F35
1 x Crank Vent Kit #6 T7 4cyl
1 x T7 Head Plug NGK
1 x BBS Center Cap for 9-2x RK small caps
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Replacement Filter for Open air 9-3 T7
2 x Sparkplugs 9-3SS
1 x Basic Subframe Brace
1 x Balance Shaft Tensioner Delete
1 x Rear Engine Mount 4cyl
1 x Fog light 9-3 left 99-00
1 x Direct Ignition T5 RED
1 x Cabin Vent Fan
2 x Genuine Saab 4cyl Oil Filters
1 x Intake Flange B2x4 T5
1 x Metal Steering Wheel Buttons
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Oil Cap GM "HHR"
1 x Short Shifter HHR Cobalt F35 F40
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x v6oilcoolplate
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x c900 Performance Brake lines
$24,303.99
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail