$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x T7 3.5 Bar Fuel Pressure Regulator
2 x 9-5 Intercooler ETS
3 x Drop in Sport Filter 9-5
2 x SCNA Christmas Calendar
1 x Viggen Titanium KeyChain
2 x Saab black Keychain
1 x Fog light Replacement Panels 99-01
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x BSR 9-5 3.0T V6 200Hp
5 x PPC - Upgrade from stage 1 to stage 3
2 x Con Rods V6 2.8L 155.8mm
2 x Limit Strap Coilover Add On Kit
3 x Clear Little Fender Blinkers Factory Saab
1 x Replacement V6 Coolant Cap
1 x Injectors Green Giant 42lb (set 4)
1 x Injectors Siemens 80lb 875cc (set 4)
2 x Head Bolt Washers
2 x T5 3.0 Bar Map Sensor Adaptor
1 x Injectors Siemens 60lb 630cc (set 4)
1 x Moog Ball Joint
1 x Map/MAT sensor weld bung
1 x Universal / Special Request
2 x 9000 Shifter Bushing Repair Kit
2 x Intake Flange B2x4 T5
2 x Troll Head Plug
1 x c900 Performance Brake lines
1 x AEM Wideband Gauge Kit
1 x IAT Weld Bung T5/Bosch
1 x Rivetnuts Pair (2pcs)
2 x Fuel Line Clip
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
6 x Mass Airflow Meter T7
2 x Crank Vent Kit #6 T7 4cyl
1 x 9-5 Open Air Prefilter
2 x 20th Viggen logo Shifter Top
1 x Rear spring perches Adjustable NG900/9-3
2 x Rear Camber Shims Kit 6pcs
1 x 9-5 Blend Flap Limit Lever 99-04
1 x 9-3 / 900 Uprated Front ARB Bushings
2 x Head Stud Kit all 4cyl
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
3 x Adaptor Harness Handsfree 01-
1 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 99-02,03 CV Antenna Adaptor
3 x Headbolts (New Style)
2 x Rear Engine Mount 4cyl
1 x Exhaust Clamp Kit
2 x Rod Bearings only Pauter Rods
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Replacement Filter for Open air 9-3 T7
2 x Replacement Hardware Pack 6-Point
1 x 9-3 Rear Ashtray
2 x Griffin logo Shifter Top
1 x Downpipe Hardware Kit
2 x Crush Sleeve F35 F25
2 x Genuine Saab 4cyl Oil Filters
2 x Balance Shaft Tensioner Delete
1 x 4340 Connecting Rods B204 B235
1 x 9-5 Aero Sill Protection
1 x Replacement Flywheel Insert NG900/9-3
1 x Shifter Top Ghost Logo
1 x Transmission Nut F35 F25
1 x Slave Cyl
1 x Viggen Fog Air Intake
2 x 9-3 /NG900 Grille
1 x Throttle Bend for T5 94-99
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
2 x Quaife Differential 9-5 and Viggen (F35)
2 x Aluminum Flywheel For NG900/9-3
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Flywheel Twin Disk 7.25in B2xx
1 x Fog light Replacement Panels
4 x Shift Rod Bushings
2 x Fog light 9-3 left 99-00
2 x Oil Cooler Adaptor B2X5
1 x Fog light 9-3 Right 99-00
2 x Antenna Plug NG900/9-3 hatchback
1 x 9-3 ng900 Hood Protection Strip
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Alu Hybrid Flywheel For NG900/9-3
2 x ARP Ring Gear Bolts F25/F35
1 x 9-5 Wheel 10-Spoke 16in.
2 x Mat Set Textile Shark Grey 9-5 10-
2 x Mat Set Black Rubber 9-5 10-
2 x Oil Cap 9-3SS V6 "Griffin"
2 x Mat Set Textile Jet Black 9-5 10-
1 x 9-5 Wheel 5-Spoke Twin 17in
2 x Oil Cap 9-3SS V6 "Ghost"
2 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
2 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x BSR Optiflow Intake 4cyl
1 x Rear Brake Pads 9-5 Later Style
1 x Steering Coupler 9-3 99-02
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
2 x Oil Cap 9-3SS "Ghost"
1 x B207 Upper Radiator Coolant T
2 x Shifter Mount Kit 93ss
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
3 x Aero Clutch Kit 9-5
3 x Forge Bypass Valve Cobalt/HHR TC
1 x Short Shifter HHR Cobalt F35 F40
2 x Oil Cap GM "HHR"
3 x Shifter Mount Kit Cobalt/ HHR
2 x Cat Back Exh for 9-5 Aero 04-, All 06-
1 x Brake Vac pump seals
1 x Valve Cover Gasket Set 4cyl
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x 9-3/NG900 Shift Knobs Leather
1 x B207 Coolant Cap
1 x Turbo Bypass Valve
1 x Direct Ignition T5 RED
1 x Oil Filter Re-locator
1 x Upgrade Valve Springs T5 Cars
1 x Viggen Front Brake Disk Pair 308mm
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
2 x T7 Injector Spacer Kit
1 x BBS Center Cap for 9-2x RK small caps
1 x 9-5 Rear Brake rotor See Description
1 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
1 x Front Camber Adjustment Bolts
1 x Metal Steering Wheel Buttons
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Bulb Switch Light
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Headlight Bulb H7 Longer Life
1 x Hood Emblem 9-3 SS/sc 03- All
1 x Injectors 175hp Stg3 (Set4)
1 x Mat Set Textile Parchment 9-5 10-
1 x Oil Pressure Switch
2 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Machined Control Arm Kit
1 x Exhaust manifold Stud Kit
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Midpipe 2.8T FWD (2wd)
1 x Rear Rotors PAIR 278mm Plain (Code: BA)
$32,411.70
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail