$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

After doing the front install, I thought others would benefit from my mistakes. I installed the kit on a MY95 900.

Tools Needed:
Flat Blade screwdriver
11,14,17mm Socket
Jack and Jack Stands
Drain Pan
10mm Flare (Brake Line) Wrench
Channel Locks
7mm Allen (Hex) wrench
19,24mm Open-End Wrench
Torque Wrench

Jack up front of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (Flat blade and 17mm).

Place drain pan under caliper.

Remove banjo (from brake line to caliper) bolt, try to find the brass washers on both sides of the bolt (11mm socket).

Disconnect the solid brake line from flexible house, the 10mm little nut on top of the mounting tab not the 17mm on the bottom of the mounting tab. The 17mm can be used to hold the line in place if need be, I did not need to. (10mm flare wrench).

Remove clip securing the flexible line to the mounting point, slide the line out of the mounting point (channel locks).

Install new brake line to caliper, the fitting should be angled away from the caliper. Make sure to put a new brass washer on each side of the banjo bolt. Also, make sure the brake line does not interfere with accessing the caliper guide pin. (14mm socket, torque wrench, 7mm allen wrench).

Install new line into mounting point, hold bottom with 19mm wrench and tighten bolt with 24mm wrench (19,24mm wrench).

Install solid brake line into fitting on end of SS line (10mm flare wrench).

Bleed Brakes.

Re-install wheel/tire and lower vehicle.

I will write instructions for the rear lines as a separate review.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x T7 3.5 Bar Fuel Pressure Regulator
2 x 9-5 Intercooler ETS
3 x Drop in Sport Filter 9-5
2 x SCNA Christmas Calendar
1 x Viggen Titanium KeyChain
2 x Saab black Keychain
1 x Fog light Replacement Panels 99-01
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x BSR 9-5 3.0T V6 200Hp
5 x PPC - Upgrade from stage 1 to stage 3
2 x Con Rods V6 2.8L 155.8mm
2 x Limit Strap Coilover Add On Kit
3 x Clear Little Fender Blinkers Factory Saab
1 x Replacement V6 Coolant Cap
1 x Injectors Green Giant 42lb (set 4)
1 x Injectors Siemens 80lb 875cc (set 4)
2 x Head Bolt Washers
2 x T5 3.0 Bar Map Sensor Adaptor
1 x Injectors Siemens 60lb 630cc (set 4)
1 x Moog Ball Joint
1 x Map/MAT sensor weld bung
1 x Universal / Special Request
2 x 9000 Shifter Bushing Repair Kit
2 x Intake Flange B2x4 T5
2 x Troll Head Plug
1 x c900 Performance Brake lines
1 x AEM Wideband Gauge Kit
1 x IAT Weld Bung T5/Bosch
1 x Rivetnuts Pair (2pcs)
2 x Fuel Line Clip
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
6 x Mass Airflow Meter T7
2 x Crank Vent Kit #6 T7 4cyl
1 x 9-5 Open Air Prefilter
2 x 20th Viggen logo Shifter Top
1 x Rear spring perches Adjustable NG900/9-3
2 x Rear Camber Shims Kit 6pcs
1 x 9-5 Blend Flap Limit Lever 99-04
1 x 9-3 / 900 Uprated Front ARB Bushings
2 x Head Stud Kit all 4cyl
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
3 x Adaptor Harness Handsfree 01-
1 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 99-02,03 CV Antenna Adaptor
3 x Headbolts (New Style)
2 x Rear Engine Mount 4cyl
1 x Exhaust Clamp Kit
2 x Rod Bearings only Pauter Rods
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Replacement Filter for Open air 9-3 T7
2 x Replacement Hardware Pack 6-Point
1 x 9-3 Rear Ashtray
2 x Griffin logo Shifter Top
1 x Downpipe Hardware Kit
2 x Crush Sleeve F35 F25
2 x Genuine Saab 4cyl Oil Filters
2 x Balance Shaft Tensioner Delete
1 x 4340 Connecting Rods B204 B235
1 x 9-5 Aero Sill Protection
1 x Replacement Flywheel Insert NG900/9-3
1 x Shifter Top Ghost Logo
1 x Transmission Nut F35 F25
1 x Slave Cyl
1 x Viggen Fog Air Intake
2 x 9-3 /NG900 Grille
1 x Throttle Bend for T5 94-99
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Quaife Differential 9-5 and Viggen (F35)
2 x Aluminum Flywheel For NG900/9-3
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Flywheel Twin Disk 7.25in B2xx
1 x Fog light Replacement Panels
4 x Shift Rod Bushings
2 x Fog light 9-3 left 99-00
2 x Oil Cooler Adaptor B2X5
1 x Fog light 9-3 Right 99-00
2 x Antenna Plug NG900/9-3 hatchback
1 x 9-3 ng900 Hood Protection Strip
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Alu Hybrid Flywheel For NG900/9-3
2 x ARP Ring Gear Bolts F25/F35
1 x 9-5 Wheel 10-Spoke 16in.
2 x Mat Set Textile Shark Grey 9-5 10-
2 x Mat Set Black Rubber 9-5 10-
2 x Oil Cap 9-3SS V6 "Griffin"
2 x Mat Set Textile Jet Black 9-5 10-
1 x 9-5 Wheel 5-Spoke Twin 17in
2 x Oil Cap 9-3SS V6 "Ghost"
2 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
2 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x BSR Optiflow Intake 4cyl
1 x Rear Brake Pads 9-5 Later Style
1 x Steering Coupler 9-3 99-02
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
2 x Oil Cap 9-3SS "Ghost"
1 x B207 Upper Radiator Coolant T
2 x Shifter Mount Kit 93ss
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
3 x Aero Clutch Kit 9-5
3 x Forge Bypass Valve Cobalt/HHR TC
1 x Short Shifter HHR Cobalt F35 F40
2 x Oil Cap GM "HHR"
3 x Shifter Mount Kit Cobalt/ HHR
2 x Cat Back Exh for 9-5 Aero 04-, All 06-
1 x Brake Vac pump seals
1 x Valve Cover Gasket Set 4cyl
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x 9-3/NG900 Shift Knobs Leather
1 x B207 Coolant Cap
1 x Turbo Bypass Valve
1 x Direct Ignition T5 RED
1 x Oil Filter Re-locator
1 x Upgrade Valve Springs T5 Cars
1 x Viggen Front Brake Disk Pair 308mm
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x T7 Injector Spacer Kit
1 x BBS Center Cap for 9-2x RK small caps
1 x 9-5 Rear Brake rotor See Description
1 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
1 x Front Camber Adjustment Bolts
1 x Metal Steering Wheel Buttons
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Bulb Switch Light
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Headlight Bulb H7 Longer Life
1 x Hood Emblem 9-3 SS/sc 03- All
1 x Injectors 175hp Stg3 (Set4)
1 x Mat Set Textile Parchment 9-5 10-
1 x Oil Pressure Switch
2 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Machined Control Arm Kit
1 x Exhaust manifold Stud Kit
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Midpipe 2.8T FWD (2wd)
1 x Rear Rotors PAIR 278mm Plain (Code: BA)
$31,056.70
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail