$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x Air Filter 06 version (All 9-5)
1 x 9-5 Rear Brake rotor See Description
3 x 9-5 Rear Brake rotor VENTED 300mm See Desc
3 x 9-5 AERO 308mm Front Brake Rotor / Disk
5 x PPC - Upgrade from stage 1 to stage 3
1 x 9-3 /NG900 Grille
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
2 x 9-3 ng900 Hood Protection Strip
3 x 9-3/NG900 Shift Knobs Leather
3 x 9-5 Shift Knobs Leather
2 x Alu Hybrid Flywheel For NG900/9-3
2 x JE Piston Rings 90.0mm 235/205
3 x JE Piston Ring (1cyl) 90.5mm 235/205/204
3 x T7 Head Plug NGK
5 x Shift Rod Bushings
2 x Rod Bearings only Pauter Rods
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Flywheel Twin Disk 7.25in B2xx
3 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Replacement Flywheel Insert NG900/9-3
1 x ARP Ring Gear Bolts F25/F35
1 x Aluminum Flywheel For NG900/9-3
1 x Quaife Differential 9-5 and Viggen (F35)
2 x 9-3 Rear Ashtray
1 x 20th Viggen logo Shifter Top
2 x Slave Cyl
2 x Headbolts (New Style)
1 x 9-3 ng900 radio wires
1 x Griffin logo Shifter Top
1 x Oil Filter Re-locator
2 x Floormats BSR 9-3 99-02 900 94-98
3 x Sport Transmission Mount 9-3/900 (Automatic)
2 x Adaptor Harness Handsfree 01-
2 x 4340 Connecting Rods B204 B235
1 x Coreganizer
3 x Head Stud Kit all 4cyl
1 x Shifter Top Ghost Logo
2 x Machined Control Arm Kit
1 x 9-3 / 900 Uprated Front ARB Bushings
2 x Basic Subframe Brace
1 x Viggen Titanium KeyChain
2 x Replacement Hardware Pack 6-Point
2 x Direct Ignition T7 Black
1 x Remote Button NG900
1 x Exhaust Clamp Kit
1 x Viggen Fog Air Intake
1 x Downpipe Hardware Kit
1 x Turbo Conversion Pipe 900 9-3 T5
2 x Fuel Line Clip
2 x Crank Vent Kit #6 T7 4cyl
3 x Genuine Saab 4cyl Oil Filters
1 x T7 Injector Spacer Kit
2 x Replacement Filter for Open air 9-3 T7
1 x Throttle Bend for T5 94-99
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x Crush Sleeve F35 F25
2 x Mass Airflow Meter T7
1 x T7 3.5 Bar Fuel Pressure Regulator
2 x Direct Ignition T5 RED
1 x Oil Cooler Adaptor B2X5
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Intake Flange B2x4 T5
1 x Injectors Green Giant 42lb (set 4)
1 x Universal / Special Request
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Moog Ball Joint
1 x IAT Weld Bung T5/Bosch
1 x Headlight Bulb H7 Longer Life
1 x Midpipe 2.0T 07-11 FWD (2wd)
3 x Optical Cable Connector (Onstar Delete)
1 x Cigarette Lighter
1 x Headlight Connector Repair Kit 9-3SS 9-5
3 x Viggen Clutch Kit 99-02
1 x c900 Performance Brake lines
2 x Sparkplugs 9-3SS
1 x Turbo Bypass Valve
2 x Bulb Switch Light
1 x Rear Rotors PAIR 292mm XWD (Code: BC)
2 x Oil Pressure Switch
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
3 x MTF0063 Manual Gear oil
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Coolant Bypass Valve 9-5
3 x Clear Little Fender Blinkers Factory Saab
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
2 x Fog light 9-3 Right 99-00
1 x Valve Cover Gasket Set 4cyl
1 x Viggen Front Brake Disk Pair 308mm
2 x Rear Rotors PAIR 292mm Plain (Code: BB)
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x Front Rotors PAIR 285mm Plain (Code: AA)
2 x Mat Set Black Rubber 9-5 10-
1 x Upgrade Valve Springs T5 Cars
1 x Fog light 9-3 left 99-00
2 x Antenna Plug NG900/9-3 hatchback
1 x Rear spring perches Adjustable NG900/9-3
2 x Steering Coupler 9-3 99-02
1 x Limit Strap Coilover Add On Kit
2 x 9-5 Textile Mats 98-07
1 x Filter 9-5 Cabin Air
1 x BSR 9-5 260Hp 2006-
3 x PPC 3 Volvo Diagnostic System
1 x BSR 9-5 3.0T V6 200Hp
1 x Throttle Body T7
2 x Custom Brake Lines RR 300mm Kit
1 x Steering Rod Bushings NG900/93
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Rear Rotors PAIR 278mm Plain (Code: BA)
2 x Rear Engine Mount 4cyl
1 x Rear Brake Pads 9-5 Later Style
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Mat Set Textile Jet Black 9-5 10-
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x Transmission Nut F35 F25
1 x Storage Tray / Ashtray Kit 9-5 10-
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-5 Aero Sill Protection
1 x 9000 Shifter Bushing Repair Kit
1 x Balance Shaft Tensioner Delete
1 x Rear Brake Pads 9-3 SS
1 x Mat Set Textile Shark Grey 9-5 10-
$29,312.50
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail