$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x c900 Performance Brake lines
4 x Clear Little Fender Blinkers Factory Saab
2 x Ceramic Low Dust Brake Pads 9-3 SS
1 x Rear Rotors PAIR 292mm Plain (Code: BB)
2 x Rear Brake Pads 9-3 SS
1 x Rear Rotors PAIR 292mm XWD (Code: BC)
2 x Rear Rotors PAIR 278mm Plain (Code: BA)
2 x 9-3 SS Akebono Rear Pads
1 x 9-3 / 900 Uprated Front ARB Bushings
2 x 9-5 Blend Flap Limit Lever 99-04
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x B207 Upper Radiator Coolant T
1 x SCNA Christmas Calendar
1 x Headlight Connector Repair Kit 9-3SS 9-5
2 x 9000 Shifter Bushing Repair Kit
4 x Brake Vac pump seals
2 x Hood Emblem 9-3 SS/sc 03- All
1 x K&N Filter Service Kit
1 x V6 Tank Float - SparePart
1 x Troll Head Plug
2 x B207 Coolant Cap
1 x ATF Saab 3309 (Automatic 02->)
2 x T7 Head Plug NGK
1 x Sparkplugs 9-3SS
2 x Replacement V6 Coolant Cap
2 x MTF0063 Manual Gear oil
3 x Limit Strap Coilover Add On Kit
1 x Con Rods V6 2.8L 155.8mm
1 x Shifter Alignment Pins (Set 2)
1 x Optical Cable Connector (Onstar Delete)
2 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Floormats BSR 9-3SS/SC
1 x Rivetnuts Pair (2pcs)
1 x Front Camber Adjustment Bolts
1 x BSR Optiflow Intake 4cyl w SAI
2 x Midpipe 2.0T 07-11 FWD (2wd)
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x BSR 9-5 3.0T V6 200Hp
1 x BSR Optiflow Intake 4cyl
1 x BSR 9-5 260Hp 2006-
2 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x 9-5 Aero Sill Protection
2 x Shift Rod Bushings
2 x BSR Optiflow Intake V6 2.8t
1 x Flywheel Twin Disk 7.25in B2xx
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Aluminum Flywheel For NG900/9-3
1 x Viggen Fog Air Intake
1 x T7 3.5 Bar Fuel Pressure Regulator
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x ARP Ring Gear Bolts F25/F35
2 x Oil Cooler Adaptor B2X5
2 x PPC - Upgrade from stage 1 to stage 3
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Shifter Top Ghost Logo
1 x Slave Cyl
2 x Alu Hybrid Flywheel For NG900/9-3
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Replacement Flywheel Insert NG900/9-3
1 x T7 Injector Spacer Kit
1 x Rear Engine Mount 4cyl
1 x Quaife Differential 9-5 and Viggen (F35)
1 x JE Piston Rings 90.0mm 235/205
1 x Fog light 9-3 left 99-00
1 x Adaptor Harness Handsfree 01-
1 x Oil Filter Re-locator
1 x Antenna Plug NG900/9-3 hatchback
1 x Crank Vent Kit #6 T7 4cyl
1 x 9-3 ng900 radio wires
2 x Cat back for Viggen 2.5in
1 x Steering Coupler 9-3 99-02
1 x 9-3 /NG900 Grille
1 x Exhaust Clamp Kit
2 x Floormats BSR 9-3 99-02 900 94-98
1 x Fog light Replacement Panels
1 x 20th Viggen logo Shifter Top
1 x Downpipe Hardware Kit
1 x 9-3 ng900 Hood Protection Strip
2 x Fuel Line Clip
2 x ARP Exhaust Manifold Stud kit Stainless
1 x Replacement Filter for Open air 9-3 T7
2 x Brembo Kit 315mm Hawk HPS Pads
1 x Intake Flange B2x4 T5
1 x Brembo Brake Kit 315mm 9-5 02-->
1 x IAT Weld Bung T5/Bosch
2 x Exhaust manifold Stud Kit
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Head Bolt Washers
1 x Midpipe 2.8T XWD (4wd)
1 x Midpipe 2.8T FWD (2wd)
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Basic Subframe Brace
1 x Downpipe 2.8T FWD (2wd)
1 x Griffin logo Shifter Top
1 x Balance Shaft Tensioner Delete
1 x Map/MAT sensor weld bung
1 x Downpipe 2.8T XWD (4wd)
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x v6oilcoolplate
1 x 9-5 Textile Mats 98-07
2 x 9-5 High Performance Brake Line Kit
3 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Cabin Vent Fan
3 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
2 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x Saab black Keychain
1 x Rear Camber Shims Kit 6pcs
1 x ShortShift Kit 93ss
2 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x Custom Brake Lines RR 300mm Kit
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x 3 Point Hardware
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
2 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x BSR Optiflow Replacement Filter V6 2.8
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x v6 2.8t SAI Delete Kit
1 x Transmission Nut F35 F25
$30,706.43
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail