$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x K&N Filter Service Kit
5 x Shifter Alignment Pins (Set 2)
1 x c900 Performance Brake lines
4 x Clear Little Fender Blinkers Factory Saab
1 x 9-5 Exhaust Flex Pipe Stainless
4 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Slave Cyl
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
3 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
3 x Direct Ignition T7 Black
2 x Spec Light Flywheel For 9-5 4cyl 99-09
2 x Coolant Bypass Valve 9-5
2 x Mass Airflow Meter T7
4 x Crush Sleeve F35 F25
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x 9-3 / 900 Uprated Front ARB Bushings
2 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Bulb Switch Light
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
2 x BSR 9-5 260Hp 2006-
2 x Head Stud Kit all 4cyl
4 x PPC - Upgrade from stage 1 to stage 3
2 x Floormats BSR 9-5
1 x 9-5 Blend Flap Limit Lever 99-04
1 x 9-5 Shift Knobs Leather
1 x BSR 9-5 3.0T V6 200Hp
1 x Cigarette Lighter
1 x 9-5 Wheel 10-Spoke 16in.
2 x 9-5 Aero Sill Protection
2 x Rear Camber Shims Kit 6pcs
2 x 9-5 Intercooler ETS
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Drop in Sport Filter 9-5
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
2 x Hood Emblem 9-5 All
2 x Fog light 9-5 Aero 04-05, 06-08 All Right
2 x Fog light Replacement Panels 99-01
3 x ARP Exhaust Manifold Stud kit Stainless
2 x Exhaust manifold Stud Kit
2 x T7 Injector Spacer Kit
2 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Mat Set Textile Parchment 9-5 10-
2 x Mat Set Black Rubber 9-5 10-
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Mat Set Textile Jet Black 9-5 10-
3 x Storage Tray / Ashtray Kit 9-5 10-
3 x Oil Cap 9-3SS V6 "Ghost"
2 x Shift Rod Bushings
1 x Antenna Plug NG900/9-3 hatchback
1 x Shifter Mount Kit 93ss
1 x 9-3 Rear Ashtray
1 x Aluminum Flywheel For NG900/9-3
2 x B207 Coolant Cap
2 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
3 x Steering Coupler 9-3 99-02
1 x Oil Cap GM "HHR"
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Oil Cooler Adaptor B2X5
2 x Alu Hybrid Flywheel For NG900/9-3
2 x B207 Upper Radiator Coolant T
1 x Weld Bungs -Taper- Race Only
1 x Rivetnuts Pair (2pcs)
1 x Injectors Green Giant 42lb (set 4)
1 x Intake Flange B2x4 T5
1 x Fuel Pressure Regulator 4.0 bar
1 x IAT Weld Bung T5/Bosch
1 x Moog Ball Joint
2 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Injectors Siemens 80lb 875cc (set 4)
2 x Genuine Saab 4cyl Oil Filters
1 x Forge Bypass Valve Cobalt/HHR TC
2 x Shifter Mount Kit Cobalt/ HHR
1 x Short Shifter HHR Cobalt F35 F40
2 x Replacement Hardware Pack 6-Point
3 x Crank Vent Kit #6 T7 4cyl
1 x Headlight Bulb H7 Longer Life
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x 9-5 Textile Mats 98-07
2 x Air Filter 06 version (All 9-5)
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
1 x Open Air Intake 9000 93-98
1 x BBS Center Cap for 9-2x RK small caps
2 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Head Bolt Washers
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x Viggen Front Brake Disk Pair 308mm
1 x Transmission Nut F35 F25
1 x Steering Rod Bushings NG900/93
1 x Adaptor Harness Handsfree 01-
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x Front Camber Adjustment Bolts
1 x Direct Ignition T5 RED
1 x 9000 High Performance Brake Line Kit '95-'98
1 x BSR 9-5 2010-2011 V6 300Hp
1 x 9-5 High Performance Brake Line Kit
3 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x Replacement V6 Coolant Cap
1 x V6 Tank Float - SparePart
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Brake Vac pump seals
1 x Upgrade Valve Springs T5 Cars
1 x Turbo Bypass Valve
2 x 9-5 Open Air Prefilter
1 x Coreganizer
1 x Front Rotors PAIR 302mm Plain (Code: AB)
1 x Fog light 9-3 Right 99-00
1 x Front Rotors PAIR 285mm Plain (Code: AA)
1 x Ceramic Low Dust Brake Pads 9-3 SS
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Sparkplugs 9-3SS
1 x Fuel Line Clip
1 x Downpipe Hardware Kit
2 x Exhaust Clamp Kit
1 x Replacement Filter for Open air 9-3 T7
1 x Rear Engine Mount 4cyl
2 x Remote Button NG900
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Rear Rotors PAIR 278mm Plain (Code: BA)
1 x 9000 Intercooler ETS
1 x 4 Cyl 2.0 Coolant Tank
$27,372.47
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail