$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x T5 3.0 Bar Map Sensor Adaptor
3 x Universal / Special Request
2 x Rivetnuts Pair (2pcs)
3 x IAT Weld Bung T5/Bosch
4 x Moog Ball Joint
1 x Injectors Green Giant 42lb (set 4)
4 x Injectors Siemens 60lb 630cc (set 4)
4 x PPC - Upgrade from stage 1 to stage 3
3 x Map/MAT sensor weld bung
2 x Injectors Siemens 80lb 875cc (set 4)
3 x Header Flange 1/2in Blended Transition B2x4,B2x5
5 x Shifter Alignment Pins (Set 2)
2 x T7 Head Plug NGK
2 x 9000 Shifter Bushing Repair Kit
1 x Con Rods V6 2.8L 155.8mm
2 x c900 Performance Brake lines
2 x Troll Head Plug
1 x Viggen Titanium KeyChain
4 x SCNA Christmas Calendar
2 x B207 Coolant Cap
2 x Saab black Keychain
4 x Clear Little Fender Blinkers Factory Saab
2 x Replacement V6 Coolant Cap
1 x Limit Strap Coilover Add On Kit
2 x Shifter Mount Kit Cobalt/ HHR
2 x Short Shifter HHR Cobalt F35 F40
2 x BSR Optiflow Intake 4cyl
1 x Metal Steering Wheel Buttons
1 x BSR Optiflow Intake V6 2.8t
2 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
2 x Basic Subframe Brace
2 x Sport Transmission Mount 9-3/900 (Automatic)
2 x Machined Control Arm Kit
3 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x Steering Coupler 9-3 99-02
2 x Quaife Differential 9-5 and Viggen (F35)
1 x ARP Ring Gear Bolts F25/F35
1 x Rear spring perches Adjustable NG900/9-3
2 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
2 x T7 3.5 Bar Fuel Pressure Regulator
1 x Flywheel Twin Disk 7.25in B2xx
3 x 9-3 / 900 Uprated Front ARB Bushings
2 x T7 Injector Spacer Kit
1 x ARP Exhaust Manifold Stud kit Stainless
1 x JE Piston Rings 90.0mm 235/205
3 x Rear Engine Mount 4cyl
2 x Viggen Fog Air Intake
3 x Exhaust Clamp Kit
1 x Head Stud Kit all 4cyl
1 x Oil Filter Re-locator
2 x Slave Cyl
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
3 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
3 x Shifter Top Ghost Logo
2 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
2 x Throttle Bend for T5 94-99
2 x Oil Cooler Adaptor B2X5
3 x Transmission Nut F35 F25
4 x Flex Pipe 900 94-98 9-3 99-02
1 x Rod Bearings only Pauter Rods
2 x Rear Camber Shims Kit 6pcs
1 x Alu Hybrid Flywheel For NG900/9-3
3 x Shift Rod Bushings
2 x 9-5 Blend Flap Limit Lever 99-04
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
3 x Brake Vac pump seals
1 x Fog light Replacement Panels
3 x ShortShift Kit 93ss
2 x Crush Sleeve F35 F25
1 x Genuine Saab 4cyl Oil Filters
1 x Fog light 9-3 Right 99-00
2 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Ignition Coil 9-3SS 2.8t and 2.8T
2 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
2 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x Downpipe Hardware Kit
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x B207 Upper Radiator Coolant T
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x 9-3 ng900 Hood Protection Strip
2 x Replacement Filter for Open air 9-3 T7
1 x Front Camber Adjustment Bolts
2 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x 9-3 /NG900 Grille
2 x Direct Ignition T5 RED
1 x Optical Cable Connector (Onstar Delete)
3 x Crank Vent Kit #6 T7 4cyl
1 x Headlight Connector Repair Kit 9-3SS 9-5
2 x Mass Airflow Meter T7
1 x Shifter Mount Kit 93ss
3 x Direct Ignition T7 Black
2 x 3 Point Hardware
1 x Sparkplugs 9-3SS
1 x Replacement Hardware Pack 6-Point
2 x Fuel Line Clip
1 x V6 Tank Float - SparePart
1 x Hood Emblem 9-3 SS/sc 03- All
1 x Antenna Plug NG900/9-3 hatchback
1 x Fog light 9-3 left 99-00
1 x Remote Button NG900
1 x 9-5 Wheel 5-Spoke Twin 17in
4 x Header Flange Stainless Blended Transition B2x4,B2x5
2 x Intake Flange B2x4 T5
1 x Head Bolt Washers
1 x Weld Bungs -Taper- Race Only
2 x Headbolts (New Style)
1 x 9-5 Open Air Prefilter
2 x 9-5 Exhaust Flex Pipe Stainless
1 x Headlight Bulb H7 Longer Life
1 x Cabin Vent Fan
2 x Oil Cap 9-3SS "Ghost"
1 x 4 Cyl 2.0 Coolant Tank
1 x v6 2.8t SAI Delete Kit
1 x AEM Wideband Gauge Kit
1 x Fuel Pressure Regulator 4.0 bar
2 x ATF Saab 3309 (Automatic 02->)
2 x K&N Filter Service Kit
1 x Hawk HPS FRONT Pads 9-3 TurboX (345mm)
1 x Front Rotors PAIR 285mm Plain (Code: AA)
1 x Viggen Clutch Kit 99-02
1 x Replacement Flywheel Insert NG900/9-3
1 x BSR 9-5 260Hp 2006-
1 x Brembo Kit 315mm Hawk HPS Pads
1 x Exhaust manifold Stud Kit
1 x Steering Rod Bushings NG900/93
1 x Brembo Brake Kit 315mm 9-3 SS
1 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Throttle Body T7
1 x BBS Center Cap for 9-2x RK small caps
1 x 9-5 Wheel 10-Spoke 16in.
2 x Valve Cover Gasket Set 4cyl
1 x Filter 9-5 Cabin Air
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Rear Pedestal Spoiler 9-3 SS
1 x v6oilcoolplate
1 x Drop in Sport Filter 9-5
1 x Midpipe 2.8T XWD (4wd)
1 x Midpipe 2.8T FWD (2wd)
$37,289.30
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail