$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x Exhaust manifold Stud Kit
5 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x ARP Exhaust Manifold Stud kit Stainless
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
3 x T7 Injector Spacer Kit
2 x c900 Performance Brake lines
2 x 9-3/NG900 Shift Knobs Leather
1 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3 Rear Ashtray
1 x 9-3 ng900 radio wires
1 x Adaptor Harness Handsfree 01-
2 x Griffin logo Shifter Top
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Coreganizer
2 x 20th Viggen logo Shifter Top
1 x PPC 3 Volvo Diagnostic System
1 x Oil Filter Re-locator
3 x T7 Head Plug NGK
1 x Balance Shaft Tensioner Delete
1 x Head Stud Kit all 4cyl
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Rod Bearings only Pauter Rods
2 x Headbolts (New Style)
1 x JE Piston Rings 90.0mm 235/205
1 x 4340 Connecting Rods B204 B235
1 x K&N Filter Service Kit
1 x ATF Saab 3309 (Automatic 02->)
1 x Oil Cap GM "HHR"
1 x Shifter Mount Kit Cobalt/ HHR
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Shifter Alignment Pins (Set 2)
1 x MTF0063 Manual Gear oil
1 x B207 Coolant Cap
1 x Aluminum Flywheel For NG900/9-3
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Replacement Hardware Pack 6-Point
1 x Replacement Filter for Open air 9-3 T7
1 x Direct Ignition T7 Black
1 x Crank Vent Kit #6 T7 4cyl
2 x Exhaust Clamp Kit
1 x Rear Engine Mount 4cyl
2 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Direct Ignition T5 RED
1 x Crush Sleeve F35 F25
2 x Fuel Line Clip
1 x Remote Button NG900
1 x Downpipe Hardware Kit
1 x Mass Airflow Meter T7
2 x Throttle Bend for T5 94-99
1 x Viggen Fog Air Intake
2 x Saab black Keychain
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
2 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Metal Steering Wheel Buttons
1 x 9-5 Aero Sill Protection
1 x 9-5 Shift Knobs Leather
1 x 9-3 ng900 Hood Protection Strip
1 x 9-5 Textile Mats 98-07
1 x Bulb Switch Light
1 x 9-5 Blend Flap Limit Lever 99-04
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x 9000 Intercooler ETS
$13,479.26
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail