$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x Limit Strap Coilover Add On Kit
2 x Header Flange Stainless Blended Transition B2x4,B2x5
4 x Injectors Siemens 60lb 630cc (set 4)
3 x Universal / Special Request
4 x Header Flange 1/2in Blended Transition B2x4,B2x5
2 x T5 3.0 Bar Map Sensor Adaptor
2 x Injectors Green Giant 42lb (set 4)
3 x Fuel Pressure Regulator 4.0 bar
2 x AEM Wideband Gauge Kit
2 x Oil Cap GM "HHR"
1 x c900 Performance Brake lines
1 x Short Shifter HHR Cobalt F35 F40
1 x Forge Bypass Valve Cobalt/HHR TC
2 x Clear Little Fender Blinkers Factory Saab
1 x Saab black Keychain
1 x Front Camber Adjustment Bolts
1 x Steering Coupler 9-3 99-02
1 x Oil Cap 9-3SS "Ghost"
1 x 20th Viggen logo Shifter Top
1 x Oil Cooler Adaptor B2X5
2 x 9-5 Aero Sill Protection
1 x Oil Filter Re-locator
1 x v6 header flange
2 x T7 Head Plug NGK
1 x Oil Cap 9-3SS V6 "Griffin"
2 x Machined Control Arm Kit
1 x Transmission Nut F35 F25
1 x Troll Head Plug
2 x Griffin logo Shifter Top
3 x Map/MAT sensor weld bung
1 x Weld Bungs -Taper- Race Only
3 x PPC - Upgrade from stage 1 to stage 3
1 x Head Bolt Washers
1 x Midpipe 2.0T 07-11 FWD (2wd)
3 x Moog Ball Joint
1 x Rivetnuts Pair (2pcs)
1 x Direct Ignition T5 RED
2 x 9-3 / 900 Uprated Front ARB Bushings
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Rod Bearings only Pauter Rods
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x 9-5 Shift Knobs Leather
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Antenna Plug NG900/9-3 hatchback
2 x Direct Ignition T7 Black
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Genuine Saab 4cyl Oil Filters
1 x Balance Shaft Tensioner Delete
1 x JE Piston Rings 90.0mm 235/205
2 x 9-3 ng900 Hood Protection Strip
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Remote Button NG900
1 x Replacement Filter for Open air 9-3 T7
1 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-3/NG900 Shift Knobs Leather
1 x Crank Vent Kit #6 T7 4cyl
1 x Quaife Differential 9-5 and Viggen (F35)
2 x Shift Rod Bushings
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Exhaust Clamp Kit
1 x Head Stud Kit all 4cyl
1 x Hood Emblem 9-5 All
1 x Throttle Bend for T5 94-99
1 x Coolant Bypass Valve 9-5
1 x BSR 9-5 3.0T V6 200Hp
1 x Fog light Replacement Panels 99-01
1 x Fog light 9-3 Right 99-00
1 x Shifter Top Ghost Logo
2 x T7 3.5 Bar Fuel Pressure Regulator
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x Slave Cyl
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Aero Clutch Kit 9-5
1 x SCNA Christmas Calendar
1 x Ignition Coil 9-3SS 2.8t and 2.8T
2 x BSR Optiflow Intake 4cyl
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Headbolts (New Style)
1 x Viggen Front Brake Disk Pair 308mm
1 x Turbo Bypass Valve
$15,795.50
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail