$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Rivetnuts Pair (2pcs)
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
2 x Injectors Siemens 60lb 630cc (set 4)
2 x Injectors Green Giant 42lb (set 4)
2 x T5 3.0 Bar Map Sensor Adaptor
2 x Bulb Switch Light
2 x 9-5 Textile Mats 98-07
1 x 9-5 Shift Knobs Leather
2 x Adaptor Harness Handsfree 01-
1 x Shifter Mount Kit Cobalt/ HHR
2 x Filter 9-5 Cabin Air
1 x Oil Pressure Switch
1 x Air Filter 06 version (All 9-5)
2 x Crank Vent Kit #6 T7 4cyl
1 x PPC 3 Volvo Diagnostic System
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x Hood Emblem 9-5 All
2 x Fog light Replacement Panels 99-01
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
4 x Head Stud Kit all 4cyl
2 x Troll Head Plug
2 x B207 Coolant Cap
2 x T7 Injector Spacer Kit
1 x Front Camber Adjustment Bolts
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Aluminum Flywheel For NG900/9-3
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
4 x Rear Engine Mount 4cyl
1 x Flywheel Twin Disk 7.25in B2xx
1 x Transmission Nut F35 F25
1 x ARP Ring Gear Bolts F25/F35
1 x Rear Brake Pads 9-5 Later Style
1 x Coreganizer
1 x Steering Coupler 9-3 99-02
2 x Rod Bearings only Pauter Rods
1 x Cat back for Viggen 2.5in
1 x Replacement Filter for Open air 9-3 T7
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
3 x 20th Viggen logo Shifter Top
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x 4340 Connecting Rods B204 B235
1 x 9-3 Rear Ashtray
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x Exhaust Clamp Kit
3 x JE Piston Ring (1cyl) 90.5mm 235/205/204
4 x Downpipe Hardware Kit
1 x Basic Subframe Brace
2 x Steering Rod Bushings NG900/93
2 x Griffin logo Shifter Top
2 x 9-3 / 900 Uprated Front ARB Bushings
1 x 9-3 ng900 radio wires
2 x Limit Strap Coilover Add On Kit
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Headbolts (New Style)
2 x Replacement Hardware Pack 6-Point
3 x Exhaust manifold Stud Kit
2 x Rear Camber Shims Kit 6pcs
1 x T7 Head Plug NGK
2 x Fuel Line Clip
1 x 9-3/NG900 Shift Knobs Leather
2 x Machined Control Arm Kit
1 x Oil Filter Re-locator
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
2 x Brembo Brake Kit 315mm 9-5 02-->
2 x Viggen Front Brake Disk Pair 308mm
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
2 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
1 x Brembo Kit 315mm Hawk HPS Pads
2 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x 9-5 High Performance Brake Line Kit
2 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
3 x Weld Bungs -Taper- Race Only
2 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x MTF0063 Manual Gear oil
1 x Mass Airflow Meter T7
2 x Intake Flange B2x4 T5
3 x Head Bolt Washers
1 x Replacement V6 Coolant Cap
2 x AEM Wideband Gauge Kit
1 x 9-3 SS Akebono Rear Pads
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Fuel Pressure Regulator 4.0 bar
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x 9-5 Open Air Prefilter
1 x PPC - Upgrade from stage 1 to stage 3
1 x Hood Emblem 9-3 SS/sc 03- All
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x Throttle Body T7
1 x 9000 Intercooler ETS
1 x Shift Rod Bushings
2 x 9000 Shifter Bushing Repair Kit
2 x ARP Exhaust Manifold Stud kit Stainless
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x Open Air Intake 9000 93-98
1 x 9-5 Wheel 10-Spoke 16in.
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x BBS Center Cap for 9-2x RK small caps
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x v6 2.8t SAI Delete Kit
1 x Fog light Replacement Panels
1 x Brake Vac pump seals
1 x Upgrade Valve Springs T5 Cars
1 x Downpipe 2.8T FWD (2wd)
1 x Oil Cap 9-3SS V6 "Griffin"
1 x v6oilcoolplate
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x 9-3 ng900 Hood Protection Strip
1 x Rear spring perches Adjustable NG900/9-3
1 x Direct Ignition T5 RED
1 x Turbo Bypass Valve
2 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Balance Shaft Tensioner Delete
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
$26,558.10
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail