$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Headlight Connector Repair Kit 9-3SS 9-5
2 x Downpipe 2.8T XWD (4wd)
3 x Midpipe 2.8T FWD (2wd)
3 x Midpipe 2.0T 07-11 FWD (2wd)
3 x Injectors Siemens 80lb 875cc (set 4)
3 x Header Flange 1/2in Blended Transition B2x4,B2x5
6 x Fuel Pressure Regulator 4.0 bar
3 x v6 header flange
2 x Sparkplugs 9-3SS
6 x Brake Vac pump seals
2 x 9-3 / 900 Uprated Front ARB Bushings
6 x Intake Flange B2x4 T5
3 x AEM Wideband Gauge Kit
4 x Ignition Coil 9-3SS 2.0t and 2.0T
4 x v6oilcoolplate
2 x Hood Emblem 9-3 SS/sc 03- All
4 x 9-3 / 900 Uprated Suspension Bushings Inner
3 x Coreganizer
5 x Saab black Keychain
3 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x BSR Optiflow Intake V6 2.8t
6 x Shifter Mount Kit Cobalt/ HHR
4 x Rivetnuts Pair (2pcs)
6 x Exhaust manifold Stud Kit
2 x ARP Exhaust Manifold Stud kit Stainless
5 x Oil Cap GM "HHR"
2 x Turbo to Downpipe Flange B207
3 x Oil Cap 9-3SS V6 "Griffin"
5 x MTF0063 Manual Gear oil
2 x Viggen Titanium KeyChain
4 x Oil Cap 9-3SS "Ghost"
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
6 x 20th Viggen logo Shifter Top
7 x c900 Performance Brake lines
3 x Alu Hybrid Flywheel For NG900/9-3
2 x Custom Brake Lines RR 300mm Kit
4 x Goodridge Brake Lines 9-3 SS / SC 03-
4 x Custom Brake Lines Brembo 315mm 9-3SS/SC
3 x Front Camber Adjustment Bolts
1 x Mat Set Textile Shark Grey 9-5 10-
5 x Front Camber Adjustment Bolts
3 x Storage Tray / Ashtray Kit 9-5 10-
2 x Mat Set Textile Jet Black 9-5 10-
4 x Shifter Alignment Pins (Set 2)
3 x ATF Saab 3309 (Automatic 02->)
2 x BSR 9-5 260Hp 2006-
4 x B207 Upper Radiator Coolant T
3 x Brembo Brake Kit 315mm 9-5 02-->
3 x 9000 Shifter Bushing Repair Kit
5 x PPC - Upgrade from stage 1 to stage 3
4 x Brembo Brake Kit 315mm 9-3 SS
2 x Basic Subframe Brace
2 x Downpipe 2.8T FWD (2wd)
5 x Clear Little Fender Blinkers Factory Saab
3 x Fog light Replacement Panels
2 x Antenna Plug NG900/9-3 hatchback
4 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
5 x Shifter Mount Kit 93ss
4 x ShortShift Kit 93ss
2 x Torque Mount Insert V6 Manual (XWD and FWD)
4 x Short Shifter HHR Cobalt F35 F40
5 x Forge Bypass Valve Cobalt/HHR TC
2 x Head Stud Kit all 4cyl
1 x SCNA Christmas Calendar
2 x Con Rods V6 2.8L 155.8mm
1 x BBS Center Cap for 9-2x RK small caps
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
3 x Moog Ball Joint
2 x Crush Sleeve F35 F25
3 x Downpipe Hardware Kit
1 x Ceramic Low Dust Brake Pads 9-3 SS
2 x Direct Ignition T7 Black
2 x Header Flange Stainless Blended Transition B2x4,B2x5
6 x Adaptor Harness Handsfree 01-
1 x ARP Ring Gear Bolts F25/F35
2 x Slave Cyl
1 x Aluminum Flywheel For NG900/9-3
2 x Rear Engine Mount 4cyl
1 x Universal / Special Request
1 x Floormats BSR 9-3 99-02 900 94-98
2 x Injectors Green Giant 42lb (set 4)
1 x Injectors Siemens 60lb 630cc (set 4)
3 x Map/MAT sensor weld bung
2 x Mass Airflow Meter T7
3 x Head Bolt Washers
2 x Sport Transmission Mount 9-3/900 (Automatic)
3 x Shifter Top Ghost Logo
3 x Shift Rod Bushings
1 x Griffin logo Shifter Top
2 x 9-3/NG900 Shift Knobs Leather
2 x Quaife Differential 9-5 and Viggen (F35)
1 x Metal Steering Wheel Buttons
1 x 9-3 99-02,03 CV Antenna Adaptor
2 x IAT Weld Bung T5/Bosch
1 x Replacement Flywheel Insert NG900/9-3
1 x Floormats BSR 9-3SS/SC
3 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
3 x T5 3.0 Bar Map Sensor Adaptor
4 x 9-3 Rear Ashtray
1 x Rear Rotors PAIR 278mm Plain (Code: BA)
1 x JE Piston Rings 90.0mm 235/205
1 x Coolant Bypass Valve 9-5
2 x Rear Rotors PAIR 292mm XWD (Code: BC)
2 x 9-5 Wheel 10-Spoke 16in.
1 x Rod Bearings only Pauter Rods
1 x Filter 9-5 Cabin Air
2 x 9-3 SS Akebono Rear Pads
1 x Cabin Vent Fan
2 x Headbolts (New Style)
2 x Rear Rotors PAIR 292mm Plain (Code: BB)
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
2 x Genuine Saab 4cyl Oil Filters
1 x 9-5 Open Air Prefilter
4 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x 4340 Connecting Rods B204 B235
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Air Filter 06 version (All 9-5)
1 x Rear Brake Pads 9-3 SS
1 x Hood Emblem 9-5 All
3 x 9-5 Blend Flap Limit Lever 99-04
1 x Crank Vent Kit #6 T7 4cyl
3 x 9-5 Shift Knobs Leather
3 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
2 x Rear Pedestal Spoiler 9-3 SS
1 x T7 3.5 Bar Fuel Pressure Regulator
4 x Sport Transmission Mount 9-5 (Manual) 1998-1999
2 x Troll Head Plug
1 x PPC 3 Volvo Diagnostic System
1 x Spec Light Flywheel For 9-5 4cyl 99-09
3 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
3 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
3 x Optical Cable Connector (Onstar Delete)
2 x BSR Optiflow Intake 4cyl w SAI
1 x Rear spring perches Adjustable NG900/9-3
1 x T7 Head Plug NGK
6 x BSR Optiflow Intake 4cyl
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Steering Rod Bushings NG900/93
1 x BSR 9-5 2010-2011 V6 300Hp
1 x Fog light Replacement Panels 99-01
1 x Limit Strap Coilover Add On Kit
2 x Rear Camber Shims Kit 6pcs
1 x Mat Set Textile Parchment 9-5 10-
3 x Oil Cap 9-3SS V6 "Ghost"
1 x K&N Filter Service Kit
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x 9-5 Wheel 5-Spoke Twin 17in
2 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Viggen Clutch Kit 99-02
1 x Turbo Bypass Valve
1 x Throttle Body T7
2 x Viggen Front Brake Disk Pair 308mm
1 x Floormats BSR 9-5
1 x Replacement Hardware Pack 6-Point
2 x v6 2.8t SAI Delete Kit
1 x B207 Coolant Cap
1 x V6 Tank Float - SparePart
3 x Brembo Kit 315mm Hawk HPS Pads
2 x 9-5 High Performance Brake Line Kit
2 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x Rear Brake Pads 9-5 Later Style
2 x 9-3 900 9-5 REAR Brembo Disk See Descr.
2 x 9-5 286mm REAR Brembo Disk (1) See Descr.
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-3 /NG900 Grille
1 x Hawk HPS FRONT Pads 9-3 TurboX (345mm)
1 x 9-5 Rear Brake rotor See Description
1 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
1 x 9-3 ng900 Hood Protection Strip
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
2 x Fog light 9-3 Right 99-00
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
1 x Replacement Filter for Open air 9-3 T7
1 x Fog light 9-3 left 99-00
1 x Upgrade Valve Springs T5 Cars
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Weld Bungs -Taper- Race Only
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x 9-5 Textile Mats 98-07
1 x 9-5 Exhaust Flex Pipe Stainless
1 x 4 Cyl 2.0 Coolant Tank
$67,382.11
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail