$142.00

Viggen Fog Air Intake
[RamFOGvig]

Viggen Fog Air Intake

Add to Cart

Date Added: Monday 10 September, 2012

by James Nakatsu

Not the prettiest of parts that I've ever bought from Taliferro (raw aluminium sheets and pipe welded, markings to indicate where to bend, burrs still intact, etc) but it is CERTAINLY built with care.
It turns out that it uses the foglight mounting "lip" rather than the spoiler lip, so I was able to install this. I found that there was an additional pre-airbox-box (not the OEM box that houses the filter), so I removed it. I can't imagine how the original intake allowed the motor to breathe at all! Now the cone filter gets fresh air directly from this intake. With fall coming up (rapidly), I may later opt to install a mesh to reduce the "solid" debris from entering the intake area.
One thing of note is that the top bolt needs to be a tad longer. From the top, it won't reach the threads to "bite". I'll head to the hardware store to score a longer bolt with a bigger head and perhaps a rubber washer to silence any potential noise (The top bolt will seat itself in a piece of sheetmetal that is in a slight angle).

Some install reviews:
Jack up the car a bit & secure with stands.
Open bonnet.
Remove filter assembly.
Remove the fog light, and wrap the connector (weatherproof).
Zip tie the wire so it won't hang loose.
If you can see the ceiling, you're good to go.
Remove the intermediate airbox (8mm screws x2)
Confirm clear passage to filter.
Insert new duct behind foglight opening, pipe first.
Position duct so that the bottom lip sits atop the foglight bracket.
Pop in the bolts (2) from the front.
From under the car, reach into duct and hold the bolts
Install washer & locknut hand tighten.
[nut/washer/body/duct/bolt head]
From outside you can reach into duct with one hand and reach over to feel for it popping into engine compartment with other.
Once the pipe clears the opening, find the top welded nut.
Place BIG washer over nut, insert bolt (get a longer one), tighten.
Go back and tighten the two lower nuts (10mm)
Smack it with fist, wriggle it, make sure no noises occur.
Put everything back together.
Take it for a drive.
Come back to this site and write review.

Post-install Impressions...
Seemingly bit of improved throttle response (need more data)
What to do with the driver's side foglamp...?
Not the prettiest part, but looking forward to performance
One extra part to watch out for, when removing bumper
This part might double as a turbo-whine-amplifier...!!!

Again, a great product from Taliaferro!

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x Head Bolt Washers
1 x Rivetnuts Pair (2pcs)
2 x PPC 3 Volvo Diagnostic System
1 x AEM Wideband Gauge Kit
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Universal / Special Request
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Short Shifter HHR Cobalt F35 F40
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x PPC - Upgrade from stage 1 to stage 3
1 x Oil Cap GM "HHR"
1 x Shifter Mount Kit Cobalt/ HHR
2 x T5 3.0 Bar Map Sensor Adaptor
1 x Fuel Pressure Regulator 4.0 bar
1 x Map/MAT sensor weld bung
1 x Moog Ball Joint
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Intake Flange B2x4 T5
1 x Injectors Siemens 80lb 875cc (set 4)
3 x IAT Weld Bung T5/Bosch
1 x Injectors Siemens 60lb 630cc (set 4)
2 x c900 Performance Brake lines
1 x Saab black Keychain
2 x SCNA Christmas Calendar
1 x Limit Strap Coilover Add On Kit
1 x T7 Head Plug NGK
1 x B207 Coolant Cap
1 x Replacement V6 Coolant Cap
1 x 9000 Shifter Bushing Repair Kit
1 x Troll Head Plug
2 x ATF Saab 3309 (Automatic 02->)
3 x Oil Cooler Adaptor B2X5
1 x Rod Bearings only Pauter Rods
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Clear Little Fender Blinkers Factory Saab
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Antenna Plug NG900/9-3 hatchback
1 x 9-5 Aero Sill Protection
1 x 9-3 /NG900 Grille
1 x Aero Clutch Kit 9-5
2 x Machined Control Arm Kit
1 x Exhaust manifold Stud Kit
1 x v6 header flange
2 x BBS Center Cap for 9-2x RK small caps
1 x Front Camber Adjustment Bolts
1 x Genuine Saab 4cyl Oil Filters
1 x Adaptor Harness Handsfree 01-
1 x Rear Engine Mount 4cyl
1 x Balance Shaft Tensioner Delete
1 x Basic Subframe Brace
1 x Mass Airflow Meter T7
1 x Crank Vent Kit #6 T7 4cyl
1 x Fog light 9-3 Right 99-00
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Floormats BSR 9-3SS/SC
1 x Injectors Green Giant 42lb (set 4)
1 x Shift Rod Bushings
1 x Turbo Conversion Pipe 900 9-3 T5
1 x Hood Emblem 9-5 All
1 x Headlight Bulb H7 Longer Life
1 x BSR Optiflow Intake 4cyl
1 x Oil Filter Re-locator
1 x Oil Cap 9-3SS "Ghost"
1 x Shifter Top Ghost Logo
1 x 9-3 ng900 radio wires
1 x Viggen Fog Air Intake
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
$9,631.41
Manufacturer Info
Taliaferro
Other products
Share Product
Share via E-Mail