$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

After doing the front install, I thought others would benefit from my mistakes. I installed the kit on a MY95 900.

Tools Needed:
Flat Blade screwdriver
11,14,17mm Socket
Jack and Jack Stands
Drain Pan
10mm Flare (Brake Line) Wrench
Channel Locks
7mm Allen (Hex) wrench
19,24mm Open-End Wrench
Torque Wrench

Jack up front of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (Flat blade and 17mm).

Place drain pan under caliper.

Remove banjo (from brake line to caliper) bolt, try to find the brass washers on both sides of the bolt (11mm socket).

Disconnect the solid brake line from flexible house, the 10mm little nut on top of the mounting tab not the 17mm on the bottom of the mounting tab. The 17mm can be used to hold the line in place if need be, I did not need to. (10mm flare wrench).

Remove clip securing the flexible line to the mounting point, slide the line out of the mounting point (channel locks).

Install new brake line to caliper, the fitting should be angled away from the caliper. Make sure to put a new brass washer on each side of the banjo bolt. Also, make sure the brake line does not interfere with accessing the caliper guide pin. (14mm socket, torque wrench, 7mm allen wrench).

Install new line into mounting point, hold bottom with 19mm wrench and tighten bolt with 24mm wrench (19,24mm wrench).

Install solid brake line into fitting on end of SS line (10mm flare wrench).

Bleed Brakes.

Re-install wheel/tire and lower vehicle.

I will write instructions for the rear lines as a separate review.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
5 x Universal / Special Request
1 x Shifter Alignment Pins (Set 2)
2 x MTF0063 Manual Gear oil
1 x K&N Filter Service Kit
1 x Adaptor Harness Handsfree 01-
1 x Fog light Replacement Panels
2 x 9-3 Rear Ashtray
2 x Fog light Replacement Panels 99-01
2 x 3 Point Hardware
4 x Clear Little Fender Blinkers Factory Saab
1 x Griffin logo Shifter Top
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Sparkplugs 9-3SS
1 x Floormats BSR 9-3 99-02 900 94-98
1 x JE Piston Rings 90.0mm 235/205
1 x Metal Steering Wheel Buttons
2 x Head Stud Kit all 4cyl
2 x Shifter Mount Kit 93ss
3 x ARP Ring Gear Bolts F25/F35
3 x Rear Engine Mount 4cyl
2 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Replacement Flywheel Insert NG900/9-3
1 x Front Camber Adjustment Bolts
2 x Alu Hybrid Flywheel For NG900/9-3
1 x Aluminum Flywheel For NG900/9-3
2 x Transmission Nut F35 F25
1 x Flywheel Twin Disk 7.25in B2xx
1 x Slave Cyl
3 x ShortShift Kit 93ss
2 x Machined Control Arm Kit
2 x Con Rods V6 2.8L 155.8mm
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x Rear spring perches Adjustable NG900/9-3
2 x Exhaust Clamp Kit
2 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Downpipe Hardware Kit
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
3 x Limit Strap Coilover Add On Kit
1 x Throttle Bend for T5 94-99
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x T7 Head Plug NGK
1 x SCNA Christmas Calendar
2 x Steering Rod Bushings NG900/93
1 x Crush Sleeve F35 F25
2 x Replacement Filter for Open air 9-3 T7
2 x Viggen Fog Air Intake
1 x Fuel Line Clip
2 x 9-5 Aero Sill Protection
1 x Genuine Saab 4cyl Oil Filters
1 x Crank Vent Kit #6 T7 4cyl
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Direct Ignition T7 Black
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
3 x Steering Coupler 9-3 99-02
1 x T7 Injector Spacer Kit
2 x B207 Coolant Cap
1 x Turbo Conversion Pipe 900 9-3 T5
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Mass Airflow Meter T7
2 x Troll Head Plug
2 x Basic Subframe Brace
1 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x 9000 Shifter Bushing Repair Kit
1 x Direct Ignition T5 RED
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Oil Cooler Adaptor B2X5
1 x Remote Button NG900
1 x Replacement Hardware Pack 6-Point
1 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
1 x Downpipe 2.8T FWD (2wd)
1 x c900 Performance Brake lines
2 x BSR Optiflow Intake 4cyl
2 x Midpipe 2.0T 07-11 FWD (2wd)
2 x Midpipe 2.8T FWD (2wd)
1 x Downpipe 2.8T XWD (4wd)
1 x BSR Optiflow Replacement Filter V6 2.8
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x Midpipe 2.8T XWD (4wd)
1 x Exhaust manifold Stud Kit
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
2 x Cat back for Viggen 2.5in
3 x ARP Exhaust Manifold Stud kit Stainless
2 x BSR Optiflow Intake 4cyl w SAI
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Storage Tray / Ashtray Kit 9-5 10-
1 x Oil Cap 9-3SS V6 "Ghost"
2 x Mat Set Textile Jet Black 9-5 10-
1 x Mat Set Black Rubber 9-5 10-
3 x Weld Bungs -Taper- Race Only
1 x IAT Weld Bung T5/Bosch
2 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
2 x Rear Camber Shims Kit 6pcs
4 x Fuel Pressure Regulator 4.0 bar
4 x Header Flange 1/2in Blended Transition B2x4,B2x5
4 x Moog Ball Joint
2 x Intake Flange B2x4 T5
2 x PPC - Upgrade from stage 1 to stage 3
2 x Head Bolt Washers
3 x Injectors Siemens 60lb 630cc (set 4)
3 x Injectors Green Giant 42lb (set 4)
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x Air Filter 06 version (All 9-5)
1 x Oil Cap 9-3SS "Ghost"
3 x Shift Rod Bushings
1 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-5 Open Air Prefilter
2 x Oil Cap 9-3SS V6 "Griffin"
1 x V6 Tank Float - SparePart
2 x Rivetnuts Pair (2pcs)
1 x 9-3 SS Akebono Rear Pads
1 x Upgrade Valve Springs T5 Cars
1 x Custom Brake Lines RR 300mm Kit
1 x Oil Filter Re-locator
2 x 9-3 ng900 radio wires
2 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Brembo Kit 315mm Hawk HPS Pads
1 x Turbo to Downpipe Flange B207
1 x Mat Set Textile Parchment 9-5 10-
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Fog light 9-3 Right 99-00
1 x 9-3/NG900 Shift Knobs Leather
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
$28,694.31
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail