$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
6 x c900 Performance Brake lines
1 x Con Rods V6 2.8L 155.8mm
1 x Replacement V6 Coolant Cap
1 x Shifter Alignment Pins (Set 2)
2 x ATF Saab 3309 (Automatic 02->)
1 x K&N Filter Service Kit
1 x MTF0063 Manual Gear oil
2 x 9-5 Aero Sill Protection
1 x 9-3 ng900 Hood Protection Strip
1 x ARP Exhaust Manifold Stud kit Stainless
2 x 9-5 Textile Mats 98-07
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x Antenna Plug NG900/9-3 hatchback
2 x Aero Clutch Kit 9-5
1 x 9-5 Rear Brake rotor See Description
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x Drop in Sport Filter 9-5
1 x 9-5 Intercooler ETS
1 x Bulb Switch Light
1 x 9-5 Shift Knobs Leather
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x Cigarette Lighter
4 x Clear Little Fender Blinkers Factory Saab
1 x Floormats BSR 9-5
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x T7 Injector Spacer Kit
2 x Exhaust manifold Stud Kit
1 x Adaptor Harness Handsfree 01-
2 x Air Filter 06 version (All 9-5)
1 x 9-3/NG900 Shift Knobs Leather
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
2 x Crush Sleeve F35 F25
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Crank Vent Kit #6 T7 4cyl
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x Coolant Bypass Valve 9-5
1 x Headbolts (New Style)
1 x Oil Pressure Switch
1 x Downpipe Hardware Kit
1 x Headlight Bulb H7 Longer Life
1 x Cabin Vent Fan
1 x Head Stud Kit all 4cyl
1 x Fuel Line Clip
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x Mass Airflow Meter T7
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Genuine Saab 4cyl Oil Filters
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Mat Set Black Rubber 9-5 10-
1 x 9000 Intercooler ETS
1 x Shift Rod Bushings
1 x Open Air Intake 9000 93-98
1 x 9000 High Performance Brake Line Kit '95-'98
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x B207 Coolant Cap
1 x Goodridge Brake Lines 9-3 SS / SC 03-
1 x Weld Bungs -Taper- Race Only
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Intake Flange B2x4 T5
1 x PPC - Upgrade from stage 1 to stage 3
1 x Head Bolt Washers
1 x Fuel Pressure Regulator 4.0 bar
1 x IAT Weld Bung T5/Bosch
1 x Rivetnuts Pair (2pcs)
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Map/MAT sensor weld bung
1 x JE Piston Rings 90.0mm 235/205
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Balance Shaft Tensioner Delete
1 x T7 Head Plug NGK
1 x 4340 Connecting Rods B204 B235
1 x Rod Bearings only Pauter Rods
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x Oil Cooler Adaptor B2X5
1 x Viggen Clutch Kit 99-02
$13,124.25
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail