$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x Injectors Green Giant 42lb (set 4)
2 x Shifter Alignment Pins (Set 2)
7 x Clear Little Fender Blinkers Factory Saab
1 x Oil Cap GM "HHR"
2 x Saab black Keychain
4 x Shifter Mount Kit Cobalt/ HHR
6 x Intake Flange B2x4 T5
5 x Header Flange 1/2in Blended Transition B2x4,B2x5
3 x Injectors Siemens 80lb 875cc (set 4)
5 x Map/MAT sensor weld bung
2 x 3 Point Hardware
3 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
5 x Oil Cap 9-3SS V6 "Griffin"
5 x Oil Cap 9-3SS V6 "Ghost"
6 x Rivetnuts Pair (2pcs)
4 x Header Flange Stainless Blended Transition B2x4,B2x5
2 x Shifter Top Ghost Logo
3 x Turbo Conversion Pipe 900 9-3 T5
2 x Transmission Nut F35 F25
1 x Replacement Flywheel Insert NG900/9-3
3 x Alu Hybrid Flywheel For NG900/9-3
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
2 x Aluminum Flywheel For NG900/9-3
3 x Throttle Bend for T5 94-99
3 x Midpipe 2.8T FWD (2wd)
2 x Downpipe 2.8T FWD (2wd)
1 x Midpipe 2.8T XWD (4wd)
5 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
5 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
3 x BSR Optiflow Intake 4cyl w SAI
3 x Con Rods V6 2.8L 155.8mm
2 x 9000 Shifter Bushing Repair Kit
2 x BSR Optiflow Replacement Filter V6 2.8
3 x Injectors 175hp Stg3 (Set4)
2 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
5 x BSR Optiflow Intake V6 2.8t
1 x BSR 9-5 2010-2011 V6 300Hp
1 x Exhaust manifold Stud Kit
1 x BBS Center Cap for 9-2x RK small caps
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x 9-3 ng900 radio wires
3 x Front Camber Adjustment Bolts
1 x c900 Performance Brake lines
2 x Optical Cable Connector (Onstar Delete)
3 x 9-5 Rear Brake rotor See Description
1 x "Griffin" Valve stem caps
2 x Ignition Coil 9-3SS 2.0t and 2.0T
2 x 9-3/NG900 Shift Knobs Leather
2 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
2 x Sparkplugs 9-3SS
3 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
2 x 9-5 Wheel 10-Spoke 16in.
2 x Air Filter 06 version (All 9-5)
5 x 9-5 AERO 308mm Front Brake Rotor / Disk
2 x Brake Vac pump seals
2 x V6 Tank Float - SparePart
2 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
2 x 9-3 ng900 Hood Protection Strip
2 x B207 Upper Radiator Coolant T
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
1 x Headlight Connector Repair Kit 9-3SS 9-5
5 x 9-5 Aero Sill Protection
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
2 x Hood Emblem 9-3 SS/sc 03- All
1 x Aero Clutch Kit 9-5
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x 9-5 Shift Knobs Leather
1 x 9-5 Textile Mats 98-07
2 x Antenna Plug NG900/9-3 hatchback
1 x Rear Pedestal Spoiler 9-3 SS
4 x Forge Bypass Valve Cobalt/HHR TC
2 x Fog light 9-3 left 99-00
3 x MTF0063 Manual Gear oil
3 x Fog light Replacement Panels
1 x v6oilcoolplate
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Limit Strap Coilover Add On Kit
1 x Oil Filter Re-locator
2 x 9-5 Open Air Prefilter
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
4 x AEM Wideband Gauge Kit
3 x Fuel Pressure Regulator 4.0 bar
3 x SCNA Christmas Calendar
2 x Mat Set Textile Jet Black 9-5 10-
1 x Shift Rod Bushings
1 x T7 Head Plug NGK
1 x Replacement V6 Coolant Cap
1 x Troll Head Plug
3 x B207 Coolant Cap
1 x Mat Set Black Rubber 9-5 10-
2 x Mat Set Textile Shark Grey 9-5 10-
2 x IAT Weld Bung T5/Bosch
2 x 9-3 900 9-5 REAR Brembo Disk See Descr.
2 x Injectors Siemens 60lb 630cc (set 4)
3 x 9-5 High Performance Brake Line Kit
1 x Short Shifter HHR Cobalt F35 F40
5 x PPC - Upgrade from stage 1 to stage 3
2 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Moog Ball Joint
3 x T5 3.0 Bar Map Sensor Adaptor
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
1 x Rear Brake Pads 9-5 Later Style
3 x Slave Cyl
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
14 x BSR Optiflow Intake 4cyl
1 x Viggen Fog Air Intake
1 x Drop in Sport Filter 9-5
1 x ARP Ring Gear Bolts F25/F35
1 x T7 Injector Spacer Kit
1 x Front Camber Adjustment Bolts
2 x InjectorDynamics 725cc For 2.8V6 (Set6)
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
4 x 4340 Connecting Rods B204 B235
2 x Cigarette Lighter
1 x Front Rotors PAIR 285mm Plain (Code: AA)
2 x Genuine Saab 4cyl Oil Filters
2 x Viggen Front Brake Disk Pair 308mm
1 x Turbo Bypass Valve
1 x Rear Engine Mount 4cyl
1 x Remote Button NG900
1 x Rear spring perches Adjustable NG900/9-3
1 x Basic Subframe Brace
1 x Crush Sleeve F35 F25
1 x Valve Cover Gasket Set 4cyl
1 x Headlight Bulb H7 Longer Life
1 x Fuel Line Clip
1 x Coolant Bypass Valve 9-5
1 x Throttle Body T7
1 x Direct Ignition T7 Black
1 x Oil Pressure Switch
1 x Headbolts (New Style)
1 x Mass Airflow Meter T7
1 x Filter 9-5 Cabin Air
1 x Downpipe Hardware Kit
1 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x 9-3 Rear Ashtray
2 x Universal / Special Request
1 x Adaptor Harness Handsfree 01-
1 x Fog light Replacement Panels 99-01
1 x Head Bolt Washers
1 x Turbo to Downpipe Flange B207
1 x v6 2.8t SAI Delete Kit
1 x Replacement Hardware Pack 6-Point
2 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Cat back for Viggen 2.5in
1 x Rod Bearings only Pauter Rods
2 x Downpipe 2.8T XWD (4wd)
2 x 9-5 Exhaust Flex Pipe Stainless
1 x Brembo Kit 315mm Hawk HPS Pads
1 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x 9-5 Blend Flap Limit Lever 99-04
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Steering Rod Bushings NG900/93
1 x Upgrade Valve Springs T5 Cars
1 x Replacement Filter for Open air 9-3 T7
1 x Rear Rotors PAIR 292mm Plain (Code: BB)
1 x Flywheel Twin Disk 7.25in B2xx
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
$57,104.08
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail