$142.00

Viggen Fog Air Intake
[RamFOGvig]

Viggen Fog Air Intake

Add to Cart

Date Added: Monday 10 September, 2012

by James Nakatsu

Not the prettiest of parts that I've ever bought from Taliferro (raw aluminium sheets and pipe welded, markings to indicate where to bend, burrs still intact, etc) but it is CERTAINLY built with care.
It turns out that it uses the foglight mounting "lip" rather than the spoiler lip, so I was able to install this. I found that there was an additional pre-airbox-box (not the OEM box that houses the filter), so I removed it. I can't imagine how the original intake allowed the motor to breathe at all! Now the cone filter gets fresh air directly from this intake. With fall coming up (rapidly), I may later opt to install a mesh to reduce the "solid" debris from entering the intake area.
One thing of note is that the top bolt needs to be a tad longer. From the top, it won't reach the threads to "bite". I'll head to the hardware store to score a longer bolt with a bigger head and perhaps a rubber washer to silence any potential noise (The top bolt will seat itself in a piece of sheetmetal that is in a slight angle).

Some install reviews:
Jack up the car a bit & secure with stands.
Open bonnet.
Remove filter assembly.
Remove the fog light, and wrap the connector (weatherproof).
Zip tie the wire so it won't hang loose.
If you can see the ceiling, you're good to go.
Remove the intermediate airbox (8mm screws x2)
Confirm clear passage to filter.
Insert new duct behind foglight opening, pipe first.
Position duct so that the bottom lip sits atop the foglight bracket.
Pop in the bolts (2) from the front.
From under the car, reach into duct and hold the bolts
Install washer & locknut hand tighten.
[nut/washer/body/duct/bolt head]
From outside you can reach into duct with one hand and reach over to feel for it popping into engine compartment with other.
Once the pipe clears the opening, find the top welded nut.
Place BIG washer over nut, insert bolt (get a longer one), tighten.
Go back and tighten the two lower nuts (10mm)
Smack it with fist, wriggle it, make sure no noises occur.
Put everything back together.
Take it for a drive.
Come back to this site and write review.

Post-install Impressions...
Seemingly bit of improved throttle response (need more data)
What to do with the driver's side foglamp...?
Not the prettiest part, but looking forward to performance
One extra part to watch out for, when removing bumper
This part might double as a turbo-whine-amplifier...!!!

Again, a great product from Taliaferro!

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x c900 Performance Brake lines
3 x T7 Injector Spacer Kit
3 x Viggen Fog Air Intake
2 x Basic Subframe Brace
3 x Limit Strap Coilover Add On Kit
1 x Exhaust Clamp Kit
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Exhaust manifold Stud Kit
1 x Flex Pipe 900 94-98 9-3 99-02
1 x Cat back for Viggen 2.5in
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Map/MAT sensor weld bung
1 x ARP Ring Gear Bolts F25/F35
1 x Sport Transmission Mount 9-3/900 (Automatic)
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Rod Bearings only Pauter Rods
2 x T7 Head Plug NGK
1 x Shifter Top Ghost Logo
1 x B207 Coolant Cap
1 x Replacement V6 Coolant Cap
1 x Oil Filter Re-locator
1 x Rear Engine Mount 4cyl
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x Balance Shaft Tensioner Delete
3 x Shift Rod Bushings
1 x Replacement Flywheel Insert NG900/9-3
1 x JE Piston Rings 90.0mm 235/205
1 x SCNA Christmas Calendar
2 x 9000 Shifter Bushing Repair Kit
4 x Troll Head Plug
1 x Aluminum Flywheel For NG900/9-3
1 x Head Stud Kit all 4cyl
1 x Alu Hybrid Flywheel For NG900/9-3
1 x Con Rods V6 2.8L 155.8mm
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Griffin logo Shifter Top
1 x Replacement Filter for Open air 9-3 T7
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x 9-5 Aero Sill Protection
1 x Fog light 9-3 left 99-00
1 x Fog light 9-3 Right 99-00
1 x 9-3 ng900 Hood Protection Strip
1 x 9-5 Wheel 5-Spoke Twin 17in
2 x 9-3SS Wheel 5-Spoke Low Split 17 in.
3 x Throttle Bend for T5 94-99
2 x Oil Cooler Adaptor B2X5
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
2 x Turbo Conversion Pipe 900 9-3 T5
1 x T7 3.5 Bar Fuel Pressure Regulator
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x Injectors Green Giant 42lb (set 4)
2 x 9000 High Performance Brake Line Kit '95-'98
1 x Crush Sleeve F35 F25
1 x Open Air Intake 9000 93-98
1 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x Upgrade Valve Springs T5 Cars
1 x Injectors Siemens 60lb 630cc (set 4)
1 x IAT Weld Bung T5/Bosch
1 x 3 Point Hardware
1 x Front Camber Adjustment Bolts
1 x Aero Clutch Kit 9-5
1 x 9-5 Shift Knobs Leather
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x 9-5 Intercooler ETS
1 x 9000 Intercooler ETS
1 x Rear Camber Shims Kit 6pcs
1 x Steering Coupler 9-3 99-02
1 x MTF0063 Manual Gear oil
1 x 9-3 / 900 Uprated Front ARB Bushings
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Viggen Front Brake Disk Pair 308mm
2 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x v6 header flange
1 x Goodridge Brake Lines 9-3 SS / SC 03-
$15,637.09
Manufacturer Info
Taliaferro
Other products
Share Product
Share via E-Mail