$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x T5 3.0 Bar Map Sensor Adaptor
2 x AEM Wideband Gauge Kit
5 x Moog Ball Joint
5 x Forge Bypass Valve Cobalt/HHR TC
4 x IAT Weld Bung T5/Bosch
2 x Rivetnuts Pair (2pcs)
3 x Injectors Green Giant 42lb (set 4)
5 x Universal / Special Request
5 x Map/MAT sensor weld bung
3 x Shifter Mount Kit Cobalt/ HHR
1 x SCNA Christmas Calendar
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x T7 3.5 Bar Fuel Pressure Regulator
2 x Oil Cooler Adaptor B2X5
1 x Turbo Conversion Pipe 900 9-3 T5
1 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x Exhaust Clamp Kit
2 x ARP Exhaust Manifold Stud kit Stainless
1 x Cat back for Viggen 2.5in
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
2 x Exhaust manifold Stud Kit
1 x Crank Vent Kit #6 T7 4cyl
1 x Mass Airflow Meter T7
1 x Genuine Saab 4cyl Oil Filters
1 x Direct Ignition T7 Black
1 x Direct Ignition T5 RED
1 x Replacement Hardware Pack 6-Point
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Downpipe Hardware Kit
1 x Rear Engine Mount 4cyl
1 x Replacement Filter for Open air 9-3 T7
1 x Remote Button NG900
1 x PPC 3 Volvo Diagnostic System
1 x Fog light Replacement Panels
1 x T7 Head Plug NGK
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Fog light 9-3 left 99-00
5 x Clear Little Fender Blinkers Factory Saab
1 x Fog light 9-3 Right 99-00
1 x Rod Bearings only Pauter Rods
2 x 9-5 Aero Sill Protection
3 x Header Flange 1/2in Blended Transition B2x4,B2x5
2 x Weld Bungs -Taper- Race Only
1 x Intake Flange B2x4 T5
2 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
2 x Injectors Siemens 80lb 875cc (set 4)
3 x Head Bolt Washers
2 x PPC - Upgrade from stage 1 to stage 3
2 x Fuel Pressure Regulator 4.0 bar
2 x Storage Tray / Ashtray Kit 9-5 10-
2 x Oil Cap 9-3SS V6 "Ghost"
1 x Mat Set Textile Parchment 9-5 10-
1 x Mat Set Textile Jet Black 9-5 10-
2 x Injectors Siemens 60lb 630cc (set 4)
1 x Oil Cap 9-3SS V6 "Griffin"
3 x Mat Set Black Rubber 9-5 10-
2 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Coreganizer
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x Metal Steering Wheel Buttons
1 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Midpipe 2.8T XWD (4wd)
1 x Steering Coupler 9-3 99-02
1 x BSR Optiflow Intake V6 2.8t
2 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Custom Brake Lines RR 300mm Kit
1 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
1 x v6oilcoolplate
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Brake Vac pump seals
1 x Oil Cap GM "HHR"
1 x 9-3 ng900 radio wires
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x Injectors 175hp Stg3 (Set4)
1 x Downpipe 2.8T XWD (4wd)
1 x K&N Filter Service Kit
1 x Head Stud Kit all 4cyl
1 x Front Camber Adjustment Bolts
1 x Short Shifter HHR Cobalt F35 F40
1 x BSR Optiflow Intake 4cyl
1 x BSR 9-5 260Hp 2006-
$18,397.14
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail