$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
3 x c900 Performance Brake lines
3 x Fuel Pressure Regulator 4.0 bar
2 x Header Flange Stainless Blended Transition B2x4,B2x5
3 x Map/MAT sensor weld bung
1 x Shifter Mount Kit Cobalt/ HHR
2 x Shifter Alignment Pins (Set 2)
2 x B207 Coolant Cap
1 x 4340 Connecting Rods B204 B235
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Rod Bearings only Pauter Rods
1 x Oil Filter Re-locator
1 x 9-5 Exhaust Flex Pipe Stainless
3 x Rear Camber Shims Kit 6pcs
3 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Oil Pressure Switch
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
3 x Shift Rod Bushings
2 x Air Filter 06 version (All 9-5)
2 x 9-3 / 900 Uprated Front ARB Bushings
2 x Slave Cyl
2 x Genuine Saab 4cyl Oil Filters
1 x Coolant Bypass Valve 9-5
2 x T7 Injector Spacer Kit
1 x Spec Light Flywheel For 9-5 4cyl 99-09
2 x Direct Ignition T7 Black
1 x Filter 9-5 Cabin Air
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
3 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Headbolts (New Style)
2 x Downpipe Hardware Kit
1 x Steering Coupler 9-3 99-02
3 x Machined Control Arm Kit
1 x Oil Cooler Adaptor B2X5
2 x Rear spring perches Adjustable NG900/9-3
1 x Cabin Vent Fan
1 x Front Camber Adjustment Bolts
2 x Fuel Line Clip
2 x Viggen Fog Air Intake
3 x Basic Subframe Brace
1 x 9-5 Open Air Prefilter
1 x Limit Strap Coilover Add On Kit
1 x Aero Clutch Kit 9-5
2 x Turbo Conversion Pipe 900 9-3 T5
2 x Crush Sleeve F35 F25
3 x T7 3.5 Bar Fuel Pressure Regulator
1 x Sport Transmission Mount 9-3/900 (Automatic)
2 x Rear Engine Mount 4cyl
2 x Mass Airflow Meter T7
1 x Replacement Filter for Open air 9-3 T7
1 x ARP Ring Gear Bolts F25/F35
2 x Adaptor Harness Handsfree 01-
2 x 20th Viggen logo Shifter Top
1 x Crank Vent Kit #6 T7 4cyl
1 x BSR 9-5 260Hp 2006-
1 x 9-5 Blend Flap Limit Lever 99-04
1 x Flywheel Twin Disk 7.25in B2xx
2 x Transmission Nut F35 F25
1 x 9-3 /NG900 Grille
1 x Coreganizer
1 x Antenna Plug NG900/9-3 hatchback
1 x Remote Button NG900
1 x 9-3 Rear Ashtray
1 x Replacement Flywheel Insert NG900/9-3
1 x Exhaust Clamp Kit
1 x 9-3/NG900 Shift Knobs Leather
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x Shifter Top Ghost Logo
2 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Floormats BSR 9-3 99-02 900 94-98
1 x Fog light 9-3 Right 99-00
2 x Quaife Differential 9-5 and Viggen (F35)
1 x 9-3 ng900 radio wires
1 x Direct Ignition T5 RED
1 x Replacement Hardware Pack 6-Point
1 x Griffin logo Shifter Top
2 x Aluminum Flywheel For NG900/9-3
1 x Fog light Replacement Panels
2 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x 9-3 ng900 Hood Protection Strip
1 x Alu Hybrid Flywheel For NG900/9-3
1 x BSR 9-5 3.0T V6 200Hp
1 x Fog light 9-3 left 99-00
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x Optical Cable Connector (Onstar Delete)
1 x 9-5 Wheel 10-Spoke 16in.
2 x 9-5 Intercooler ETS
1 x Downpipe 2.8T FWD (2wd)
1 x Con Rods V6 2.8L 155.8mm
1 x Brake Vac pump seals
1 x Bulb Switch Light
2 x Exhaust manifold Stud Kit
1 x Cat Back Exh for 9-3 SS 03-06, CV04-06 Stainless
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x BSR Optiflow Intake V6 2.8t
1 x 9000 High Performance Brake Line Kit '95-'98
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x Cigarette Lighter
2 x Clear Little Fender Blinkers Factory Saab
4 x Forge Turbo Bypass Valve 9-3SS 2.0t 175hp
3 x ARP Exhaust Manifold Stud kit Stainless
1 x BSR Optiflow Intake 4cyl w SAI
1 x 9000 Intercooler ETS
2 x 9-5 Wheel 5-Spoke Twin 17in
1 x BSR Optiflow Replacement Filter V6 2.8
1 x Midpipe 2.0T 07-11 FWD (2wd)
1 x Midpipe 2.8T FWD (2wd)
1 x V6 Tank Float - SparePart
1 x Rear Pedestal Spoiler 9-3 SS
2 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
1 x Drop in Sport Filter 9-5
1 x Cat Back Exh Dual Exit for 9-3 SS/SC 2.8t
1 x 3 Point Hardware
1 x 9-5 Textile Mats 98-07
1 x Replacement V6 Coolant Cap
1 x Hood Emblem 9-3 SS/sc 03- All
1 x Cat Back Exh for 9000 CS, CSE AERO
1 x 9-5 Shift Knobs Leather
1 x Midpipe 2.8T XWD (4wd)
1 x Downpipe 2.8T XWD (4wd)
1 x Floormats BSR 9-5
1 x Sparkplugs 9-3SS
1 x Torque Mount Insert V6 Manual (XWD and FWD)
1 x MTF0063 Manual Gear oil
1 x Front Camber Adjustment Bolts
1 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
1 x Shifter Mount Kit 93ss
1 x 9-5 Rear Brake rotor See Description
2 x Weld Bungs -Taper- Race Only
2 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
2 x Injectors Siemens 60lb 630cc (set 4)
2 x Injectors Green Giant 42lb (set 4)
2 x Head Bolt Washers
2 x T5 3.0 Bar Map Sensor Adaptor
1 x Forge Bypass Valve Cobalt/HHR TC
1 x Universal / Special Request
2 x IAT Weld Bung T5/Bosch
1 x AEM Wideband Gauge Kit
1 x Injectors Siemens 80lb 875cc (set 4)
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
1 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x PPC - Upgrade from stage 1 to stage 3
1 x Head Stud Kit all 4cyl
1 x Valve Cover Gasket Set 4cyl
1 x Headlight Bulb H7 Longer Life
$36,688.18
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail