$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
3 x Slave Cyl
2 x 9000 Shifter Bushing Repair Kit
3 x Steering Coupler 9-3 99-02
1 x JE Piston Rings 90.0mm 235/205
2 x Exhaust Clamp Kit
2 x Rod Bearings only Pauter Rods
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
2 x Head Stud Kit all 4cyl
2 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x Headbolts (New Style)
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Balance Shaft Tensioner Delete
2 x Exhaust manifold Stud Kit
4 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Flex Pipe 900 94-98 9-3 99-02
1 x 4340 Connecting Rods B204 B235
2 x Cat back for Viggen 2.5in
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
2 x IAT Weld Bung T5/Bosch
2 x Rivetnuts Pair (2pcs)
1 x Viggen Fog Air Intake
2 x Map/MAT sensor weld bung
1 x Short Shifter HHR Cobalt F35 F40
2 x Fuel Pressure Regulator 4.0 bar
2 x Head Bolt Washers
3 x Moog Ball Joint
1 x Injectors Green Giant 42lb (set 4)
1 x T7 Injector Spacer Kit
3 x AEM Wideband Gauge Kit
4 x PPC - Upgrade from stage 1 to stage 3
1 x Shifter Mount Kit Cobalt/ HHR
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
2 x Turbo Conversion Pipe 900 9-3 T5
1 x Universal / Special Request
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Intake Flange B2x4 T5
1 x Throttle Bend for T5 94-99
2 x T5 3.0 Bar Map Sensor Adaptor
1 x Injectors Siemens 60lb 630cc (set 4)
1 x Genuine Saab 4cyl Oil Filters
1 x Replacement Filter for Open air 9-3 T7
2 x Downpipe Hardware Kit
1 x Crank Vent Kit #6 T7 4cyl
2 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
1 x BSR Optiflow Intake V6 2.8t
1 x Fuel Line Clip
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x BSR 9-5 3.0T V6 200Hp
2 x Crush Sleeve F35 F25
1 x T7 3.5 Bar Fuel Pressure Regulator
2 x Custom Brake Lines RR 300mm Kit
1 x Front Brake Pads 9-5 9-3 900 LOW DUST
1 x 9-5 Open Air Prefilter
1 x 9-3 SS Akebono Rear Pads
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
2 x 9-3 900 9-5 REAR Brembo Disk See Descr.
2 x 9-3 99-02,03 CV Antenna Adaptor
2 x V6 Tank Float - SparePart
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
1 x Viggen Front Brake Disk Pair 308mm
1 x Hawk HPS FRONT Pads 9-3 9-5 (900 97-98)
1 x Filter 9-5 Cabin Air
2 x Floormats BSR 9-3 99-02 900 94-98
1 x 9-5 Wheel 10-Spoke 16in.
1 x 9-3 Rear Ashtray
2 x Saab black Keychain
2 x 9-5 Aero Sill Protection
1 x Coreganizer
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x Injectors 175hp Stg3 (Set4)
1 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
1 x Midpipe 2.8T FWD (2wd)
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x Rear Pedestal Spoiler 9-3 SS
1 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
1 x Shifter Mount Kit 93ss
2 x 3 Point Hardware
1 x MTF0063 Manual Gear oil
2 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x Steering Rod Bushings NG900/93
2 x Machined Control Arm Kit
1 x Rear Camber Shims Kit 6pcs
2 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Basic Subframe Brace
2 x Upgrade Valve Springs T5 Cars
2 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x 4 Cyl 2.0 Coolant Tank
1 x 9-3 /NG900 Grille
1 x Clear Little Fender Blinkers Factory Saab
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
1 x Fog light Replacement Panels
2 x 20th Viggen logo Shifter Top
1 x Spec Light Flywheel For 9-5 4cyl 99-09
3 x Shift Rod Bushings
1 x BSR Optiflow Replacement Filter V6 2.8
1 x 9-3 / 900 Uprated Front ARB Bushings
2 x Aluminum Flywheel For NG900/9-3
3 x Viggen Clutch Kit 99-02
2 x Rear Engine Mount 4cyl
2 x Quaife Differential 9-5 and Viggen (F35)
2 x Transmission Nut F35 F25
2 x Flywheel Twin Disk 7.25in B2xx
1 x ARP Ring Gear Bolts F25/F35
1 x Griffin logo Shifter Top
1 x 9-5 Exhaust Flex Pipe Stainless
1 x Oil Cap 9-3SS "Ghost"
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Oil Cap GM "HHR"
1 x B207 Upper Radiator Coolant T
1 x Front Camber Adjustment Bolts
1 x 9-3 ng900 radio wires
2 x Oil Cooler Adaptor B2X5
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Alu Hybrid Flywheel For NG900/9-3
1 x v6oilcoolplate
1 x BSR Optiflow Intake 4cyl
$29,817.21
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail