$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

After doing the front install, I thought others would benefit from my mistakes. I installed the kit on a MY95 900.

Tools Needed:
Flat Blade screwdriver
11,14,17mm Socket
Jack and Jack Stands
Drain Pan
10mm Flare (Brake Line) Wrench
Channel Locks
7mm Allen (Hex) wrench
19,24mm Open-End Wrench
Torque Wrench

Jack up front of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (Flat blade and 17mm).

Place drain pan under caliper.

Remove banjo (from brake line to caliper) bolt, try to find the brass washers on both sides of the bolt (11mm socket).

Disconnect the solid brake line from flexible house, the 10mm little nut on top of the mounting tab not the 17mm on the bottom of the mounting tab. The 17mm can be used to hold the line in place if need be, I did not need to. (10mm flare wrench).

Remove clip securing the flexible line to the mounting point, slide the line out of the mounting point (channel locks).

Install new brake line to caliper, the fitting should be angled away from the caliper. Make sure to put a new brass washer on each side of the banjo bolt. Also, make sure the brake line does not interfere with accessing the caliper guide pin. (14mm socket, torque wrench, 7mm allen wrench).

Install new line into mounting point, hold bottom with 19mm wrench and tighten bolt with 24mm wrench (19,24mm wrench).

Install solid brake line into fitting on end of SS line (10mm flare wrench).

Bleed Brakes.

Re-install wheel/tire and lower vehicle.

I will write instructions for the rear lines as a separate review.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
5 x K&N Filter Service Kit
1 x Replacement V6 Coolant Cap
1 x Troll Head Plug
2 x T7 Head Plug NGK
1 x Intake Flange B2x4 T5
3 x AEM Wideband Gauge Kit
2 x Fuel Pressure Regulator 4.0 bar
2 x Head Bolt Washers
2 x Rear Engine Mount 4cyl
2 x PPC 3 Volvo Diagnostic System
3 x Shift Rod Bushings
2 x Adaptor Harness Handsfree 01-
1 x 20th Viggen logo Shifter Top
2 x Machined Control Arm Kit
2 x Steering Coupler 9-3 99-02
5 x Crush Sleeve F35 F25
1 x 9-3 99-02,03 CV Antenna Adaptor
3 x T7 3.5 Bar Fuel Pressure Regulator
2 x 9-3 ng900 radio wires
3 x Mass Airflow Meter T7
2 x 9-3 Rear Ashtray
1 x Basic Subframe Brace
2 x 9-3/NG900 Shift Knobs Leather
5 x Exhaust Clamp Kit
2 x Direct Ignition T5 RED
1 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
1 x Replacement Filter for Open air 9-3 T7
1 x Oil Cooler Adaptor B2X5
1 x Rear spring perches Adjustable NG900/9-3
2 x Rear Camber Shims Kit 6pcs
4 x Crank Vent Kit #6 T7 4cyl
2 x Flex Pipe 900 94-98 9-3 99-02
3 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x Fuel Line Clip
3 x T7 Injector Spacer Kit
2 x Downpipe Hardware Kit
2 x Throttle Bend for T5 94-99
2 x Floormats BSR 9-3 99-02 900 94-98
1 x Griffin logo Shifter Top
4 x Exhaust manifold Stud Kit
1 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x 9-3 / 900 Uprated Front ARB Bushings
3 x Remote Button NG900
2 x Direct Ignition T7 Black
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
3 x Clear Little Fender Blinkers Factory Saab
1 x Fog light 9-3 Right 99-00
1 x Oil Filter Re-locator
3 x 9-3 ng900 Hood Protection Strip
3 x Headbolts (New Style)
1 x 4340 Connecting Rods B204 B235
2 x Fog light 9-3 left 99-00
2 x Balance Shaft Tensioner Delete
1 x JE Piston Rings 90.0mm 235/205
3 x 9-3 /NG900 Grille
2 x Rod Bearings only Pauter Rods
3 x PPC - Upgrade from stage 1 to stage 3
3 x Fog light Replacement Panels
2 x Antenna Plug NG900/9-3 hatchback
1 x JE Piston Ring (1cyl) 90.5mm 235/205/204
1 x 9-5 Intercooler ETS
2 x Cabin Vent Fan
2 x Hood Emblem 9-5 All
3 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
2 x 9-5 Aero Sill Protection
2 x Headlight Bulb H7 Longer Life
1 x 9-5 Open Air Prefilter
3 x ARP Exhaust Manifold Stud kit Stainless
2 x 9-5 Textile Mats 98-07
1 x Floormats BSR 9-5
1 x Bulb Switch Light
1 x Drop in Sport Filter 9-5
2 x Cat Back Exh for 9-5 Aero 04-, All 06-
2 x Filter 9-5 Cabin Air
2 x Fog light 9-5 Aero 04-05, 06-08 All Right
2 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x 9-5 Blend Flap Limit Lever 99-04
2 x Aero Clutch Kit 9-5
3 x Genuine Saab 4cyl Oil Filters
2 x Fog light Replacement Panels 99-01
2 x Cigarette Lighter
1 x Fog light 9-5 Aero 04-05, 06-08 All Left
2 x Slave Cyl
3 x Air Filter 06 version (All 9-5)
1 x Coolant Bypass Valve 9-5
1 x Front Camber Adjustment Bolts
1 x 9-5 Exhaust Flex Pipe Stainless
1 x 9-5 Shift Knobs Leather
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x BSR 9-5 260Hp 2006-
2 x BSR 9-5 3.0T V6 200Hp
5 x Open Air Intake 9-3 00-02 and Viggen (All T7)
3 x B207 Upper Radiator Coolant T
1 x Oil Cap 9-3SS "Ghost"
1 x Oil Cap 9-3SS V6 "Ghost"
1 x Oil Cap GM "HHR"
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Alu Hybrid Flywheel For NG900/9-3
1 x BSR Optiflow Intake 4cyl w SAI
2 x Open Air Intake 9000 93-98
2 x V6 Tank Float - SparePart
2 x Hood Emblem 9-3 SS/sc 03- All
2 x Weld Bungs -Taper- Race Only
1 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
2 x 9-5 Rear Brake rotor VENTED 300mm See Desc
2 x ATF Saab 3309 (Automatic 02->)
2 x 9-5 Rear Brake rotor See Description
2 x 9-5 Wheel 10-Spoke 16in.
1 x Upgrade Valve Springs T5 Cars
1 x Replacement Hardware Pack 6-Point
1 x Shifter Alignment Pins (Set 2)
2 x MTF0063 Manual Gear oil
2 x 3 Point Hardware
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
2 x Valve Cover Gasket Set 4cyl
1 x Cat Back Exh for 9000 CS, CSE AERO
2 x Optical Cable Connector (Onstar Delete)
2 x Sparkplugs 9-3SS
2 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Saab black Keychain
1 x Ignition Coil 9-3SS 2.0t and 2.0T
2 x Rear Rotors PAIR 292mm XWD (Code: BC)
2 x Rear Rotors PAIR 278mm Plain (Code: BA)
1 x BSR Optiflow Intake 4cyl
1 x Rear Brake Pads 9-5 Later Style
1 x 9-5 High Performance Brake Line Kit
2 x 9-3 900 9-5 REAR Brembo Disk See Descr.
2 x Limit Strap Coilover Add On Kit
1 x Injectors Green Giant 42lb (set 4)
1 x Brake Vac pump seals
1 x Ignition Coil 9-3SS 2.8t and 2.8T
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Rivetnuts Pair (2pcs)
1 x Injectors Siemens 60lb 630cc (set 4)
1 x 9-5 286mm REAR Brembo Disk (1) See Descr.
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Turbo Bypass Valve
1 x Mat Set Textile Parchment 9-5 10-
1 x Mat Set Textile Shark Grey 9-5 10-
1 x Metal Steering Wheel Buttons
2 x Mat Set Black Rubber 9-5 10-
1 x Throttle Body T7
1 x Rear Rotors PAIR 292mm Plain (Code: BB)
1 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
1 x BSR 9-5 2010-2011 V6 300Hp
1 x 9-3 SS Akebono Rear Pads
1 x Custom Brake Lines RR 300mm Kit
1 x Sport Transmission Mount 9-3/900 (Automatic)
$34,814.16
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail