$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
4 x Oil Cap GM "HHR"
2 x Shifter Mount Kit Cobalt/ HHR
2 x v6oilcoolplate
5 x PPC - Upgrade from stage 1 to stage 3
2 x BSR PPC 9-3 SS/SC Aero 2.8T V6 250hp
2 x BSR PPC 9-3 SS/SC 2.0T 210hp 2007-->
3 x Torque Mount Insert V6 Manual (XWD and FWD)
3 x Front Camber Adjustment Bolts
11 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
3 x Shifter Mount Kit 93ss
3 x ShortShift Kit 93ss
1 x InjectorDynamics 725cc For 2.8V6 (Set6)
2 x B207 Coolant Cap
1 x BSR Optiflow Intake 4cyl w SAI
3 x Optical Cable Connector (Onstar Delete)
1 x B207 Upper Radiator Coolant T
1 x Ignition Coil 9-3SS 2.8t and 2.8T
2 x Ignition Coil 9-3SS 2.0t and 2.0T
1 x Transmission Nut F35 F25
2 x 9-3 / 900 Uprated Front ARB Bushings
1 x 5d Rear Window repair kit 94-02 900/9-3/9-5
1 x Oil Cooler Adaptor B2X5
1 x Genuine Saab 4cyl Oil Filters
3 x Fog light 9-3 Right 99-00
1 x Rear Engine Mount 4cyl
3 x Steering Coupler 9-3 99-02
2 x Antenna Plug NG900/9-3 hatchback
1 x Crank Vent Kit #6 T7 4cyl
2 x JE Piston Rings 90.0mm 235/205
2 x T7 Head Plug NGK
2 x Midpipe 2.0T 07-11 FWD (2wd)
3 x T7 Injector Spacer Kit
3 x 9-3 ng900 Hood Protection Strip
3 x Turbo Conversion Pipe 900 9-3 T5
1 x Direct Ignition T7 Black
1 x Rear Camber Shims Kit 6pcs
2 x T7 3.5 Bar Fuel Pressure Regulator
1 x Balance Shaft Tensioner Delete
2 x Downpipe Hardware Kit
3 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Fog light 9-3 left 99-00
2 x Viggen Fog Air Intake
1 x Direct Ignition T5 RED
3 x Exhaust Clamp Kit
3 x Basic Subframe Brace
1 x Machined Control Arm Kit
2 x Mass Airflow Meter T7
3 x Oil Filter Re-locator
2 x 9-3 /NG900 Grille
2 x Steering Rod Bushings NG900/93
1 x Griffin logo Shifter Top
1 x 9-5 Aero Sill Protection
2 x 9-3 Rear Ashtray
2 x Adaptor Harness Handsfree 01-
1 x 20th Viggen logo Shifter Top
3 x 9-3/NG900 Shift Knobs Leather
4 x Floormats BSR 9-3 99-02 900 94-98
2 x 9-3 ng900 radio wires
3 x Flex Pipe 900 94-98 9-3 99-02
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Cat back for Viggen 2.5in
1 x 9-5 Wheel 10-Spoke 16in.
1 x 9-5 Wheel 5-Spoke Twin 17in
1 x Weld Bungs -Taper- Race Only
1 x 9-5 Exhaust Flex Pipe Stainless
1 x ATF Saab 3309 (Automatic 02->)
2 x Crush Sleeve F35 F25
1 x 9-5 Textile Mats 98-07
2 x 3 Point Hardware
3 x Replacement V6 Coolant Cap
1 x Rear Brake Pads 9-3 SS
1 x Brembo Brake Kit 315mm 9-3 SS
3 x Rear Rotors PAIR 292mm XWD (Code: BC)
2 x 9-3 SS Akebono Rear Pads
1 x Front Rotors PAIR 302mm Plain (Code: AB)
1 x Custom Brake Lines Brembo 315mm 9-3SS/SC
1 x Front Rotors PAIR 285mm Plain (Code: AA)
2 x Flywheel Twin Disk 7.25in B2xx
1 x IAT Weld Bung T5/Bosch
2 x Head Bolt Washers
1 x Limit Strap Coilover Add On Kit
2 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
2 x 4 Cyl 2.0 Coolant Tank
3 x BSR PPC 9-3 SS/SC 2.0T 210hp XWD 09-
2 x BSR PPC 9-3 SS/SC TurboX and XWD 2.8T V6 280hp
2 x Short Shifter HHR Cobalt F35 F40
1 x Shifter Top Ghost Logo
1 x Fog light Replacement Panels
2 x Troll Head Plug
1 x Rear spring perches Adjustable NG900/9-3
2 x Rod Bearings only Pauter Rods
1 x 9-3 / 900 Uprated Suspension Bushings Inner
2 x Goodridge Brake Lines 9-3 SS / SC 03-
1 x BSR Optiflow Intake 4cyl
1 x Intake Flange B2x4 T5
1 x AEM Wideband Gauge Kit
1 x Exhaust manifold Stud Kit
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Moog Ball Joint
2 x Forge Turbo Bypass Valve 9-3SS 2.0T 210hp
2 x Brake Vac pump seals
1 x Open Air Intake 9-3 00-02 and Viggen (All T7)
1 x Mat Set Textile Shark Grey 9-5 10-
1 x BBS Center Cap for 9-2x RK small caps
1 x BSR Optiflow Intake V6 2.8t
1 x Map/MAT sensor weld bung
1 x Front Camber Adjustment Bolts
1 x Downpipe Flange Assy. Stainless T25/Td04 to 3in
1 x Midpipe 2.8T FWD (2wd)
1 x Saab black Keychain
1 x V6 Tank Float - SparePart
1 x Sparkplugs 9-3SS
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x v6 header flange
1 x Rear Rotors PAIR 278mm Plain (Code: BA)
2 x Sport Transmission Mount 9-3/900 (Automatic)
2 x Rear Rotors PAIR 292mm Plain (Code: BB)
1 x Floormats BSR 9-3SS/SC
1 x Viggen Front Brake Disk Pair 308mm
1 x Throttle Body T7
1 x Turbo Bypass Valve
1 x Valve Cover Gasket Set 4cyl
2 x Replacement Hardware Pack 6-Point
2 x Shifter Alignment Pins (Set 2)
1 x Headbolts (New Style)
1 x v6 2.8t SAI Delete Kit
1 x Throttle Bend for T5 94-99
1 x 4340 Connecting Rods B204 B235
1 x Performance Brake Line Kit NG900 94-98 9-3 99-02
$34,603.09
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail