$164.69

Performance Brake Line Kit NG900 94-98 9-3 99-02
[40005]

Performance Brake Line Kit NG900 94-98 9-3 99-02

Add to Cart

Date Added: Friday 25 July, 2008

by M. Luke Wisniewski

Here's the rear line instruction. This is more of a pain than the front mainly because space is tight. I did this on a M95 900.

Tools Needed:
Jack and Jack Stands
Drain pan
17mm Open-End Wrench
10,13mm Flare (Brake Line) Wrench
13,17mm Socket
Channel Locks
Torque Wrench

Jack up rear of vehicle and secure with jack stands.

Remove center cap and wheel/tire assembly (flat blade screwdriver and 17mm socket

Place drain pan under control arm, the brake fluid will leak on to the control arm and run down to its lowest point.

Disconnect the solid brake line from the caliper to the flexible line at the bracket on the control arm (10mm flare wrench).

Remove bracket that holds flexible brake line to control arm (13mm socket).

Remove clip securing flexible brake line to bracket (channel locks).

Remove solid brake line from brake limit valve (a cylinder just upstream from the flexible brake line)(13mm flare wrench).

Remove brake limit valve (17mm wrench).

Remove clip holding flexible brake line to mounting point (channel locks).

Install SS line into mounting bracket, secure with clip.

Reinstall brake limit valve (17mm wrench).

Reinstall solid brake line to brake limit valve (13mm flare wrench).

Install other end of SS line into bracket (19,24mm wrench).

Install bracket onto control arm (13mm socket).

Install solid brake line from caliper to SS line (10mm flare wrench).

Bleed brakes

Reinstall wheel/tire assembly (17mm socket, torque wrench).

Remove jack stands and lower vehicle.

Rating: 5 of 5 Stars! [5 of 5 Stars!]

Write Review Back
Manufacturers
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
1 x Viggen Titanium KeyChain
4 x Saab black Keychain
1 x Header Flange 1/2in Blended Transition B2x4,B2x5
4 x MTF0063 Manual Gear oil
3 x ATF Saab 3309 (Automatic 02->)
1 x Shifter Alignment Pins (Set 2)
1 x Aluminum Flywheel For NG900/9-3
3 x Shifter Top Ghost Logo
4 x 9-5 Aero Sill Protection
4 x 5d Rear Window repair kit 94-02 900/9-3/9-5
2 x Transmission Nut F35 F25
1 x Quaife Differential 9-5 and Viggen (F35)
1 x Rod Bearings only Pauter Rods
3 x T7 Injector Spacer Kit
2 x T7 3.5 Bar Fuel Pressure Regulator
3 x Oil Cooler Adaptor B2X5
1 x Throttle Bend for T5 94-99
1 x Adaptor Harness Handsfree 01-
5 x Shift Rod Bushings
1 x 9-3 Rear Ashtray
3 x Griffin logo Shifter Top
2 x 9-3 ng900 radio wires
2 x Catback 2.5in Exh 900/9-3 94-02 Round Tip
2 x Viggen Fog Air Intake
3 x 20th Viggen logo Shifter Top
1 x Turbo Conversion Pipe 900 9-3 T5
2 x 9-5 Rear Brake rotor See Description
1 x Air Filter 06 version (All 9-5)
2 x 9-3 / 900 Uprated Suspension Bushings Inner
1 x Rear spring perches Adjustable NG900/9-3
2 x 9-5 Textile Mats 98-07
2 x Steering Rod Bushings NG900/93
2 x Aero Clutch Kit 9-5
2 x 9-5 Wheel 5-Spoke Twin 17in
1 x 9-3, 9-5 Front Brake Rotor / Disk (Code: AD)
1 x 9-3 /NG900 Grille
3 x PPC - Upgrade from stage 1 to stage 3
1 x 9-3 / 900 Uprated Front ARB Bushings
4 x 9-3SS Wheel 5-Spoke Low Split 17 in.
1 x 9-5 AERO 308mm Front Brake Rotor / Disk
1 x 9-3 ng900 Hood Protection Strip
1 x 9-3/NG900 Shift Knobs Leather
4 x Basic Subframe Brace
1 x 9-5 Rear Brake rotor VENTED 300mm See Desc
3 x Rear Camber Shims Kit 6pcs
3 x Steering Coupler 9-3 99-02
1 x Antenna Plug NG900/9-3 hatchback
3 x 9-5 Shift Knobs Leather
2 x Machined Control Arm Kit
2 x 9-5 Wheel 10-Spoke 16in.
2 x Open Air Intake 9-3 00-02 and Viggen (All T7)
2 x Exhaust Clamp Kit
2 x Flex Pipe 900 94-98 9-3 99-02
1 x Cat back for Viggen 2.5in
2 x Catback 2.5in Exh 9-3 99-02 Wide Oval Tip (NOT VIG)
4 x Clear Little Fender Blinkers Factory Saab
1 x 3pt Subframe Brace for 9-3 SS 2003-> 2wd
2 x Fog light Replacement Panels 99-01
4 x 9-5 Blend Flap Limit Lever 99-04
4 x Crush Sleeve F35 F25
1 x Ignition Coil 9-3SS 2.0t and 2.0T
2 x V6 Tank Float - SparePart
3 x Brake Vac pump seals
1 x Oil Cap GM "HHR"
2 x BSR 9-5 2010-2011 V6 300Hp
1 x Replacement Hardware Pack 6-Point
1 x Fuel Line Clip
2 x Slave Cyl
1 x Spec Light Flywheel For 9-5 4cyl 99-09
1 x ARP Exhaust Manifold Stud kit Stainless
1 x Oil Cap 9-3SS V6 "Griffin"
1 x Front Camber Adjustment Bolts
1 x 3 Point Hardware
3 x Sport Transmission Mount 9-5 (Manual) 1998-1999
1 x v6 header flange
1 x Bulb Switch Light
1 x BSR 9-5 3.0T V6 200Hp
1 x Oil Cap 9-3SS V6 "Ghost"
3 x 9-5 Exhaust Flex Pipe Stainless
3 x Alu Hybrid Flywheel For NG900/9-3
3 x Cigarette Lighter
1 x IAT Weld Bung T5/Bosch
1 x v6oilcoolplate
2 x BBS Center Cap for 9-2x RK small caps
1 x 9-5 Intercooler ETS
1 x BSR Optiflow Intake Volvo S60 I T5 2001-2004
5 x Short Shifter NG900/9-3 94-02/9-5 (Outright Kit)
1 x T5 3.0 Bar Map Sensor Adaptor
1 x Exhaust manifold Stud Kit
1 x Cat Back Exh for 9-5 Aero 04-, All 06-
2 x Head Stud Kit all 4cyl
2 x Flywheel Twin Disk 7.25in B2xx
1 x Oil Filter Re-locator
1 x BSR 9-5 260Hp 2006-
1 x Front Camber Adjustment Bolts
1 x Floormats BSR 9-5
1 x BSR 9-5 Aero 250Hp 2004-2005 Stage E85
1 x Header Flange Stainless Blended Transition B2x4,B2x5
1 x Head Bolt Washers
1 x Filter 9-5 Cabin Air
1 x Downpipe Hardware Kit
2 x Custom Brake Lines RR 300mm Kit
1 x 9-3 900 9-5 REAR Brembo Disk See Descr.
1 x Storage Tray / Ashtray Kit 9-5 10-
1 x Front Rotors PAIR 302mm Plain (Code: AB)
1 x Direct Ignition T7 Black
1 x Optical Cable Connector (Onstar Delete)
1 x Hood Emblem 9-3 SS/sc 03- All
1 x c900 Performance Brake lines
2 x Rear Brake Pads 900 97-98, 9-3 99-02+ 03CV
2 x 9-5 High Performance Brake Line Kit
1 x Sparkplugs 9-3SS
1 x Turbo Bypass Valve
2 x Fog light 9-5 Aero 04-05, 06-08 All Left
1 x Headlight Bulb H7 Longer Life
1 x Viggen Clutch Kit 99-02
1 x Mat Set Textile Jet Black 9-5 10-
2 x Valve Cover Gasket Set 4cyl
1 x Mat Set Textile Parchment 9-5 10-
1 x Mat Set Black Rubber 9-5 10-
2 x Downpipe 2.8T FWD (2wd)
1 x Brembo Brake Kit 315mm 9-5 02-->
1 x Fog light 9-5 Aero 04-05, 06-08 All Right
1 x Headlight Connector Repair Kit 9-3SS 9-5
1 x Viggen Front Brake Disk Pair 308mm
1 x 9-3 99-02,03 CV Antenna Adaptor
1 x 9-5 Open Air Prefilter
2 x Shifter Mount Kit 93ss
2 x Short Shifter HHR Cobalt F35 F40
1 x Shifter Mount Kit Cobalt/ HHR
2 x Crank Vent Kit #6 T7 4cyl
1 x Troll Head Plug
1 x Hawk HPS FRONT Pads 9-3 TurboX (345mm)
1 x 4 Cyl 2.0 Coolant Tank
1 x Torque Mount Insert V6 Manual (XWD and FWD)
2 x B207 Coolant Cap
1 x Brembo Kit 315mm Sport Rotors Pair (For Saab)
2 x Downpipe 2.8T XWD (4wd)
1 x B207 Upper Radiator Coolant T
1 x 9000 Shifter Bushing Repair Kit
1 x Hood Emblem 9-5 All
1 x Moog Ball Joint
2 x K&N Filter Service Kit
1 x v6 2.8t SAI Delete Kit
1 x Injectors Siemens 80lb 875cc (set 4)
1 x Midpipe 2.8T XWD (4wd)
1 x Brembo Kit 315mm Hawk HPS Pads
1 x Rear Brake Pads 9-5 Later Style
1 x Throttle Body T7
1 x Headbolts (New Style)
$37,344.46
Manufacturer Info
Goodridge
Other products
Share Product
Share via E-Mail